Fire breathing is typically performed with a high flash point fuel, such as lamp oil (liquid paraffin), while fire eating is performed with low flash point fuels, such as white gas or naphtha. Highly purified fuels are preferred by fire performers due to their minimized toxicity, but other, more dangerous fuels may sometimes be used, such as ethanol, isopropanol, kerosene, gasoline, or charcoal lighter fluid. All fuels run the risk of causing pneumonitis if inhaled, however longer chain oils are more persistent than smaller molecules. Alcohols and volatile naphthas are likely to be absorbed or expelled from the body by evaporation and respiration.

VALI is most common in patients receiving mechanical ventilation for acute lung injury or acute respiratory distress syndrome (ALI/ARDS).

Possible reasons for predisposition to VALI include:

- An injured lung may be at risk for further injury

- Cyclic atelectasis is particularly common in an injured lung

Fire breather’s pneumonia is caused by the entrance of hydrocarbon fuels into the bronchial tree, usually due to accidental aspiration or inhalation during a fire performance show. Fire breathing, or fire blowing, is the act of creating a plume of fire by blowing a mouthful of fuel in a fine mist (atomization) over a source of ignition. Fire eating, or fire swallowing, is the act of putting a flaming object into the mouth and extinguishing it.

In both disciplines, the performer holds their breath until the air is clear of vapors, so as to not inhale the hazardous fumes. However, improper technique or an accident can lead to ingestion, inhalation, or aspiration of fine droplets or vapors. Fire breathing and fire eating are separate acts, but the terms are sometimes erroneously used interchangeably in the literature.

Fuel ingestion can also occur due to siphoning by mouth of fuel products.

Once inhaled, these fuels induce an inflammatory reaction in lung tissue. They are not metabolized by tissue enzymes, but undergo emulsification and become engulfed by macrophages which, with time, may disintegrate and release oily substances surrounded by fibrous tissue and giant cells.

Respiratory disease is a common and significant cause of illness and death around the world. In the US, approximately 1 billion "common colds" occur each year. A study found that in 2010, there were approximately 6.8 million emergency department visits for respiratory disorders in the U.S. for patients under the age of 18. In 2012, respiratory conditions were the most frequent reasons for hospital stays among children.

In the UK, approximately 1 in 7 individuals are affected by some form of chronic lung disease, most commonly chronic obstructive pulmonary disease, which includes asthma, chronic bronchitis and emphysema.

Respiratory diseases (including lung cancer) are responsible for over 10% of hospitalizations and over 16% of deaths in Canada.

In 2011, respiratory disease with ventilator support accounted for 93.3% of ICU utilization in the United States.

According to a recent study, the main risk factors for RA-ILD are advancing age, male sex, greater RA disease activity, rheumatoid factor (RF) positivity, and elevated titers of anticitrullinated protein antibodies such as anticyclic citrullinated peptide. Cigarette smoking also appears to increase risk of RA-ILD, especially in patients with human leukocyte antigen DRB1.

A recently published retrospective study by a team from Beijing Chao-Yang Hospital in Beijing, China, supported three of the risk factors listed for RA-ILD and identified an additional risk factor. In that study of 550 RA patients, logistic regression analysis of data collected on the 237 (43%) with ILD revealed that age, smoking, RF positivity, and elevated lactate dehydrogenase closely correlated with ILD.

Recent studies have identified risk factors for disease progression and mortality. A retrospective study of 167 patients with RA-ILD determined that the usual interstitial pneumonia (UIP) pattern on high-resolution computed tomography (HRCT) was a risk factor for progression, as were severe disease upon diagnosis and rate of change in pulmonary function test results in the first 6 months after diagnosis.

A study of 59 RA-ILD patients found no median survival difference between those with the UIP pattern and those without it. But the UIP group had more deaths, hospital admissions, need for supplemental oxygen, and decline in lung function.

"Fire-eater's lung" is an important variant of hydrocarbon pneumonitis, which typically involves adolescents or young adults who are exposed through mishap during flame-blowing performances using a variety of different flammable materials. The substances used overlap with some of the pediatric exposures (kerosene, gasoline) but can also include other hydrocarbons such as jet fuel and, in France, an aromatic hydrocarbon enriched petroleum-distillate called "kerdan". There has also been a case of citronella oil aspiration in a fire-eater. As with hydrocarbon pneumonitis in children, fire-eater's lung can also be complicated by pneumatocele. Although the term "acute lipoid pneumonia" has been used to refer to the "fire-eater's lung" syndrome, this is a misnomer.

24 percent of all patients mechanically ventilated will develop VALI for reasons other than ALI or ARDS. The incidence is probably higher among patients who already have ALI/ARDS, but estimates vary widely. The variable estimates reflect the difficulty in distinguishing VALI from progressive ALI/ARDS.

Flock worker's lung is caused by exposure to small pieces of flock, usually nylon, created during the flocking process and inhaled. Exposure to rotary-cut flock particulates is the main risk factor; whether or not other types of flock cause this pulmonary fibrosis is not yet determined. Other types of flock include rayon, polypropylene, and polyethylene. Workers exposed to nylon, polypropylene, polyethylene, and rayon flocking debris have developed flock worker's lung. Exposure to higher concentrations of respirable flock particles is associated with more severe disease.

Whether or not smoking affects the progression or incidence of flock worker's lung is a topic of ongoing research as of 2015. Research in rats has shown that nylon flocking is a causative agent.

Hydrocarbon pneumonitis is a kind of chemical pneumonitis which occurs with oral ingestion of hydrocarbons and associated aspiration. It occurs prominently among children, accounting for many hospital admissions each year. Common hydrocarbons involved are mineral spirits, mineral seal oil (common in furniture polish), lamp oil, kerosene (paraffin), turpentine (pine oil), gasoline, and lighter fluid. Pneumatocele is a complication of hydrocarbon pneumonitis. In both childhood and adult pneumonitis, hydrocarbon aspiration occurs at the time of initial ingestion event or subsequently with vomiting. Low viscosity of an ingested hydrocarbon is considered a major factor promoting aspiration (presumably for mechanical reasons). Contrary to aspiration hydrocarbon pneumonitis, hydrocarbon (solvent) vapor inhalation manifests primarily in either central nervous system or cardiac effects.

Pulmonary diseases may also impact newborns, such as pulmonary hyperplasia, pulmonary interstitial emphysema (usually preterm births), and infant respiratory distress syndrome,

Health care professionals are at risk of occupational influenza exposure; during a pandemic influenza, anyone in a close environment is at risk, including those in an office environment.

Tobacco smoke is a known carcinogen. Workers in the hospitality industry may be exposed to tobacco smoke in the workplace, especially in environments like casinos and bars/restaurants.

Flock worker's lung can be prevented with engineering controls that protect workers from inhaling flock. Engineering controls to prevent inhalation of flock can include using guillotine cutters rather than rotary cutters, and ensuring that blades are sharp, since dull blades shear off more respirable particles. Flocking plants have also implemented medical surveillance programs for workers to diagnose cases at an earlier stage. Another technique for preventing flock worker's lung is cleaning the workplace with alternatives to compressed air in order to avoid resuspending particulates in the air.

Smoking is also linked to susceptibility to infectious diseases, particularly in the lungs. Smoking more than 20 cigarettes a day increases the risk of by two to four times, and being a current smoker has been linked to a fourfold increase in the risk of invasive pneumococcal disease. It is believed that smoking increases the risk of these and other pulmonary and respiratory tract infections both through structural damage and through effects on the immune system. The effects on the immune system include an increase in CD4+ cell production attributable to nicotine, which has tentatively been linked to increased HIV susceptibility.

Smoking increases the risk of Kaposi's sarcoma in people without HIV infection. One study found this only with the male population and could not draw any conclusions for the female participants in the study.

Perhaps the most serious oral condition that can arise is that of oral cancer. However, smoking also increases the risk for various other oral diseases, some almost completely exclusive to tobacco users. The National Institutes of Health, through the National Cancer Institute, determined in 1998 that "cigar smoking causes a variety of cancers including cancers of the oral cavity (lip, tongue, mouth, throat), esophagus, larynx, and lung." Pipe smoking involves significant health risks, particularly oral cancer. Roughly half of periodontitis or inflammation around the teeth cases are attributed to current or former smoking. Smokeless tobacco causes gingival recession and white mucosal lesions. Up to 90% of periodontitis patients who are not helped by common modes of treatment are smokers. Smokers have significantly greater loss of bone height than nonsmokers, and the trend can be extended to pipe smokers to have more bone loss than nonsmokers. Smoking has been proven to be an important factor in the staining of teeth. Halitosis or bad breath is common among tobacco smokers. Tooth loss has been shown to be 2 to 3 times higher in smokers than in non-smokers. In addition, complications may further include leukoplakia, the adherent white plaques or patches on the mucous membranes of the oral cavity, including the tongue.

Asbestos can cause lung cancer that is identical to lung cancer from other causes. Exposure to asbestos is associated with all major histological types of lung carcinoma (adenocarcinoma, squamous cell carcinoma, large-cell carcinoma and small-cell carcinoma). The latency period between exposure and development of lung cancer is 20 to 30 years. It is estimated that 3%-8% of all lung cancers are related to asbestos. The risk of developing lung cancer depends on the level, duration, and frequency of asbestos exposure (cumulative exposure). Smoking and individual susceptibility are other contributing factors towards lung cancer. Smokers who have been exposed to asbestos are at far greater risk of lung cancer. Smoking and asbestos exposure have a multiplicative (synergistic) effect on the risk of lung cancer. Symptoms include chronic cough, chest pain, breathlessness, haemoptysis (coughing up blood), wheezing or hoarseness of the voice, weight loss and fatigue. Treatment involves surgical removal of the cancer, chemotherapy, radiotherapy, or a combination of these (multimodality treatment). Prognosis is generally poor unless the cancer is detected in its early stages. Out of all patients diagnosed with lung cancer, only 15% survive for five years after diagnosis.

Conditions which commonly involve hemoptysis include bronchitis and pneumonia, lung cancers and tuberculosis. Other possible underlying causes include aspergilloma, bronchiectasis, coccidioidomycosis, pulmonary embolism, pneumonic plague, and cystic fibrosis. Rarer causes include hereditary hemorrhagic telangiectasia (HHT or Rendu-Osler-Weber syndrome), Goodpasture's syndrome, and granulomatosis with polyangiitis. In children, hemoptysis is commonly caused by the presence of a foreign body in the airway. The condition can also result from over-anticoagulation from treatment by drugs such as warfarin.

Blood-laced mucus from the sinus or nose area can sometimes be misidentified as symptomatic of hemoptysis (such secretions can be a sign of nasal or sinus cancer, but also a sinus infection). Extensive non-respiratory injury can also cause one to cough up blood. Cardiac causes like congestive heart failure and mitral stenosis should be ruled out.

The origin of blood can be identified by observing its color. Bright-red, foamy blood comes from the respiratory tract, whereas dark-red, coffee-colored blood comes from the gastrointestinal tract. Sometimes hemoptysis may be rust-colored.

The most common cause of minor hemoptysis is bronchitis.

- Lung cancer, including both non-small cell lung carcinoma and small cell lung carcinoma.

- Sarcoidosis

- Aspergilloma

- Tuberculosis

- Histoplasmosis

- Pneumonia

- Pulmonary edema

- Pulmonary embolism

- Foreign body aspiration and aspiration pneumonia

- Goodpasture's syndrome

- Granulomatosis with polyangiitis

- Eosinophilic granulomatosis with polyangiitis (Churg-Strauss syndrome)

- Bronchitis

- Bronchiectasis

- Pulmonary embolism

- Anticoagulant use

- Trauma

- Lung abscess

- Mitral stenosis

- Tropical eosinophilia

- Bleeding disorders

- Hughes-Stovin Syndrome and other variants of Behçet's disease

- Squamous Cell Carcinoma Of Esophagus

ILD may be classified according to the cause. One method of classification is as follows:

1. Inhaled substances

- Inorganic

- Silicosis

- Asbestosis

- Berylliosis

- printing workers (eg. carbon bblack, ink mist)

- Organic

- Hypersensitivity pneumonitis

2. Drug-induced

- Antibiotics

- Chemotherapeutic drugs

- Antiarrhythmic agents

3. Connective tissue and Autoimmune diseases

- Rheumatoid arthritis

- Systemic lupus erythematosus

- Systemic sclerosis

- Polymyositis

- Dermatomyositis

4. Infection

- Atypical pneumonia

- Pneumocystis pneumonia (PCP)

- Tuberculosis

- "Chlamydia" trachomatis

- Respiratory Syncytial Virus

5. Idiopathic

- Sarcoidosis

- Idiopathic pulmonary fibrosis

- Hamman-Rich syndrome

- Antisynthetase syndrome

6. Malignancy

- Lymphangitic carcinomatosis

7. Predominantly in children

- Diffuse developmental disorders

- Growth abnormalities deficient alveolarisation

- Infant conditions of undefined cause

- ILD related to alveolar surfactant region

Carbon monoxide (CO) is presumed to be a complication in smoke inhalation. The initial approach to presumed CO poisoning involves administering supplemental oxygen at a fraction of inspired oxygen (FiO2) of 100 percent and then the use of hyperbaric oxygen (HBO) therapy is evaluated by physicians.

The exact cause of rheumatoid lung disease is unknown. However, associated factors could be due largely to smoking. Sometimes, the medicines used to treat rheumatoid arthritis, especially methotrexate, may result in lung disease.

Prevention's:

- Stop smoking: Chemicals found in cigarettes can irritate already delicate lung tissue, leading to further complications.

- Having regular checkups: The doctor could listen to lungs and monitor breathing, because lung problems that are detected early can be easier to treat.

The National Institute of Occupational Safety and Health, Japan (JNIOSH) set limits for acceptable exposure at 0.0003 mg/m after the discovery of indium lung. Methods for reducing indium exposure are thought to be the best mode of protection. Medical surveillance of indium workers is also a method of prevention.

Smoke inhalation is the primary cause of death for victims of indoor fires. The inhalation or exposure to hot gaseous products of combustion can cause serious respiratory complications.

Some 50–80% of fire deaths are the result of smoke inhalation injuries, including burns to the respiratory system. The hot smoke injures or kills by a combination of thermal damage, poisoning and pulmonary irritation and swelling, caused by carbon monoxide, cyanide and other combustion products.

The morbidity associated with DIPNECH is due to the associated obstructive lung disease. The lung disease tends to be slowly progressive, but given enough time can lead to significant disability and require supplemental oxygen therapy. There have been reports of lung transplantation in the setting of end-stage DIPNECH.

Pneumonia is a form of acute respiratory infection that affects the lung parenchyma and oxygenation. When a patient with pneumonia is an alcoholic, the mortality rate exceeds by 50% if they are placed into intensive care (ICU). According to Kershaw, C 2008 page 1, "[a]s of 2001, pneumonia was the sixth most common cause of death in the United States". Alcoholics are at an increased risk for infection with tissue-damaging gram-negative pathogens or for the spread of bacteria in the blood.

Hemoptysis is the coughing up of blood or blood-stained mucus from the bronchi, larynx, trachea, or lungs. This can occur with lung cancer, infections such as tuberculosis, bronchitis, or pneumonia, and certain cardiovascular conditions. Hemoptysis is considered massive at . In such cases, there are always severe injuries. The primary danger comes from choking, rather than blood loss.