Several trials investigated a possible therapy for ESS. However, they yielded inconsistent and partly contradictory results. This may be caused by the fact that the investigated populations were too heterogeneous in the lack of a consistent definition of "non-thyroid illness syndrome".

Modern theories regard the TACITUS syndrome as an adaptive and therefore possibly beneficial response of thyroid homeostasis. Their proponents are therefore reserved with respect to substitutive treatment.

Affected patients may have normal, low, or slightly elevated TSH depending on the spectrum of illness. Total T4 and T3 levels may be altered by binding protein abnormalities, and medications. Reverse T3 levels are generally increased signifying inhibition of normal type 1 deiodinase or reduced clearance of reverse T3. Correspondingly, in the majority of cases calculated sum activity of peripheral deiodinases (SPINA-GD) is reduced. Generally the levels of free T3 will be lowered, followed by the lowering of free T4 in more severe disease. Several studies described elevated concentrations of 3,5-T2, an active thyroid hormone, in NTIS. 3,5-T2 levels were also observed to correlate with concentrations of rT3 (reverse T3) in patients with euthyroid sick syndrome.

TACITUS syndrome is a component of a complex endocrine adaptation process. Therefore, affected patients might also have hyperprolactinemia and elevated levels of corticosteroids (especially cortisol) and growth hormone.

Screening for hypothyroidism is performed in the newborn period in many countries, generally using TSH. This has led to the early identification of many cases and thus the prevention of developmental delay. It is the most widely used newborn screening test worldwide. While TSH-based screening will identify the most common causes, the addition of T testing is required to pick up the rarer central causes of neonatal hypothyroidism. If T determination is included in the screening done at birth, this will identify cases of congenital hypothyroidism of central origin in 1:16,000 to 1:160,000 children. Considering that these children usually have other pituitary hormone deficiencies, early identification of these cases may prevent complications.

In adults, widespread screening of the general population is a matter of debate. Some organizations (such as the United States Preventive Services Task Force) state that evidence is insufficient to support routine screening, while others (such as the American Thyroid Association) recommend either intermittent testing above a certain age in both sexes or only in women. Targeted screening may be appropriate in a number of situations where hypothyroidism is common: other autoimmune diseases, a strong family history of thyroid disease, those who have received radioiodine or other radiation therapy to the neck, those who have previously undergone thyroid surgery, those with an abnormal thyroid examination, those with psychiatric disorders, people taking amiodarone or lithium, and those with a number of health conditions (such as certain heart and skin conditions). Yearly thyroid function tests are recommended in people with Down syndrome, as they are at higher risk of thyroid disease.

Growth hormone deficiency is almost certain if all other pituitary tests are also abnormal, and insulin-like growth factor 1 (IGF-1) levels are decreased. If this is not the case, IGF-1 levels are poorly predictive of the presence of GH deficiency; stimulation testing with the insulin tolerance test is then required. This is performed by administering insulin to lower the blood sugar to a level below 2.2 mmol/l. Once this occurs, growth hormone levels are measured. If they are low despite the stimulatory effect of the low blood sugars, growth hormone deficiency is confirmed. The test is not without risks, especially in those prone to seizures or are known to have heart disease, and causes the unpleasant symptoms of hypoglycemia. Alternative tests (such as the growth hormone releasing hormone stimulation test) are less useful, although a stimulation test with arginine may be used for diagnosis, especially in situations where an insulin tolerance test is thought to be too dangerous. If GH deficiency is suspected, and all other pituitary hormones are normal, two different stimulation tests are needed for confirmation.

If morning cortisol levels are over 500 nmol/l, ACTH deficiency is unlikely, whereas a level less than 100 is indicative. Levels between 100-500 require a stimulation test. This, too, is done with the insulin tolerance test. A cortisol level above 500 after achieving a low blood sugar rules out ACTH deficiency, while lower levels confirm the diagnosis. A similar stimulation test using corticotropin-releasing hormone (CRH) is not sensitive enough for the purposes of the investigation. If the insulin tolerance test yields an abnormal result, a further test measuring the response of the adrenal glands to synthetic ACTH (the ACTH stimulation test) can be performed to confirm the diagnosis. Stimulation testing with metyrapone is an alternative. Some suggest that an ACTH stimulation test is sufficient as first-line investigation, and that an insulin tolerance test is only needed if the ACTH test is equivocal. The insulin tolerance test is discouraged in children. None of the tests for ACTH deficiency are perfect, and further tests after a period of time may be needed if initial results are not conclusive.

Symptoms of diabetes insipidus should prompt a formal fluid deprivation test to assess the body's response to dehydration, which normally causes concentration of the urine and increasing osmolarity of the blood. If these parameters are unchanged, desmopressin (an ADH analogue) is administered. If the urine then becomes concentrated and the blood osmolarity falls, there is a lack of ADH due to lack of pituitary function ("cranial diabetes insipidus"). In contrast, there is no change if the kidneys are unresponsive to ADH due to a different problem ("nephrogenic diabetes insipidus").

If one of these tests shows a deficiency of hormones produced by the pituitary, magnetic resonance imaging (MRI) scan of the pituitary is the first step in identifying an underlying cause. MRI may show various tumors and may assist in delineating other causes. Tumors smaller than 1 cm are referred to as "microadenomas", and larger lesions are called "macroadenomas". Computed tomography with radiocontrast may be used if MRI is not available. Formal visual field testing by perimetry is recommended, as this would show evidence of optic nerve compression by a tumor.

Other tests that may assist in the diagnosis of hypopituitarism, especially if no tumor is found on the MRI scan, are ferritin (elevated in hemochromatosis), angiotensin converting enzyme (ACE) levels (often elevated in sarcoidosis), and human chorionic gonadotropin (often elevated in tumor of germ cell origin). If a genetic cause is suspected, genetic testing may be performed.

Autoantibodies to the thyroid gland may be detected in various disease states. There are several anti-thyroid antibodies, including anti-thyroglobulin antibodies (TgAb), anti-microsomal/anti-thyroid peroxidase antibodies (TPOAb), and TSH receptor antibodies (TSHRAb).

- Elevated anti-thryoglobulin (TgAb) and anti-thyroid peroxidase antibodies (TPOAb) can be found in patients with Hashimoto's thyroiditis, the most common autoimmune type of hypothyroidism. TPOAb levels have also been found to be elevated in patients who present with subclinical hypothyroidism (where TSH is elevated, but free T4 is normal), and can help predict progression to overt hypothyroidism. The American Association Thyroid Association thus recommends measuring TPOAb levels when evaluating subclinical hypothyroidism or when trying to identify whether nodular thyroid disease is due to autoimmune thyroid disease.

- When the etiology of hyperthyroidism is not clear after initial clinical and biochemical evaluation, measurement of TSH receptor antibodies (TSHRAb) can help make the diagnosis. In Grave's disease, TSHRAb levels are elevated as they are responsible for activating the TSH receptor and causing increased thyroid hormone production.

During pregnancy, the thyroid gland must produce 50% more thyroid hormone to provide enough thyroid hormone for the developing fetus and the expectant mother. In pregnancy, free thyroxine levels may be lower than anticipated due to increased binding to thyroid binding globulin and decreased binding to albumin. They should either be corrected for the stage of pregnancy, or total thyroxine levels should be used instead for diagnosis. TSH values may also be lower than normal (particularly in the first trimester) and the normal range should be adjusted for the stage of pregnancy.

In pregnancy, subclinical hypothyroidism is defined as a TSH between 2.5 and 10 mIU/l with a normal thyroxine level, while those with TSH above 10 mIU/l are considered to be overtly hypothyroid even if the thyroxine level is normal. Antibodies against TPO may be important in making decisions about treatment, and should, therefore, be determined in women with abnormal thyroid function tests.

Determination of TPO antibodies may be considered as part of the assessment of recurrent miscarriage, as subtle thyroid dysfunction can be associated with pregnancy loss, but this recommendation is not universal, and presence of thyroid antibodies may not predict future outcome.

A medical biopsy refers to the obtaining of a tissue sample for examination under the microscope or other testing, usually to distinguish cancer from noncancerous conditions. Thyroid tissue may be obtained for biopsy by fine needle aspiration (FNA) or by surgery.

Fine needle aspiration has the advantage of being a brief, safe, outpatient procedure that is safer and less expensive than surgery and does not leave a visible scar. Needle biopsies became widely used in the 1980s, but it was recognized that the accuracy of identification of cancer was good, but not perfect. The accuracy of the diagnosis depends on obtaining tissue from all of the suspicious areas of an abnormal thyroid gland. The reliability of fine needle aspiration is increased when sampling can be guided by ultrasound, and over the last 15 years, this has become the preferred method for thyroid biopsy in North America.

As with hyperthyroidism, TSH is suppressed. Both free and serum (or total) T3 and T4 are elevated. An elevation in thyroid hormone levels is suggestive of thyroid storm when accompanied by signs of severe hyperthyroidism but is not diagnostic as it may also correlate with uncomplicated hyperthyroidism. Moreover, serum T3 may be normal in critically ill patients due to decreased conversion of T4 to T3. Other potential abnormalities include the following:

- Hyperglycemia likely due to catecholamine-mediated effects on insulin release and metabolism as well as increased glycogenolysis, evolving into hypoglycemia when glycogen stores are depleted

- Elevated aspartate aminotransferase (AST), bilirubin and lactate dehydrogenase (LDH)

- Hypercalcemia and elevated alkaline phosphatase due to increased bone resorption

- Elevated white blood cell count

The diagnosis of thyroid storm is based on the presence of symptoms consistent with severe hyperthyroidism, as outlined in the Signs and symptoms section above. Multiple approaches have been proposed to calculate the probability of thyroid storm based on clinical criteria, however, none have been universally adopted by clinicians. For instance, Burch and Wartofsky published the Burch-Wartofsky point scale (BWPS) in 1993, assigning a numerical value based on the presence of specific signs and symptoms organized within the following categories: temperature, cardiovascular dysfunction (including heart rate and presence of atrial fibrillation or congestive heart failure), central nervous system (CNS) dysfunction, gastrointestinal or liver dysfunction and presence of a precipitating event. A Burch-Wartofsky score below 25 is not suggestive of thyroid storm whereas 25 to 45 suggests impending thyroid storm and greater than 45 suggests current thyroid storm. Alternatively, the Japanese Thyroid Association (JTA) criteria, derived from a large cohort of patients with thyroid storm in Japan and published in 2012, provide a qualitative method to determine the probability of thyroid storm. The JTA criteria separate the diagnosis of thyroid storm into definite versus suspected based on the specific combination of signs and symptoms a patient exhibits and require elevated free triiodothyronine (T3) or free thyroxine (T4) for definite thyroid storm.

The characteristic blood test results for this disorder can also be found in other disorders (for example TSH-oma (pituitary adenoma), or other pituitary disorders). The diagnosis may involve identifying a mutation of the thyroid receptor, which is present in approximately 85% of cases.

Yet, since discovery of resistance to thyroid hormones in the absence of thyroid hormone receptor beta mutations, lack of a mutation in a patient does not rule out resistance.

Blood tests may be done prior to or in lieu of a biopsy. The possibility of a nodule which secretes thyroid hormone (which is less likely to be cancer) or hypothyroidism is investigated by measuring thyroid stimulating hormone (TSH), and the thyroid hormones thyroxine (T4) and triiodothyronine (T3).

Tests for serum thyroid autoantibodies are sometimes done as these may indicate autoimmune thyroid disease (which can mimic nodular disease).

Thyroid hormone resistance syndrome is rare, incidence is variously quoted as 1 in 50,000 or 1 in 40,000 live births. More than 1000 individuals have been identified with thyroid hormone resistance, of which 85% had thyroid hormone beta receptor mutation.

Fine Needle Aspiration Cytology (FNAC) is a cheap, simple, and safe method in obtaining cytological specimens for diagnosis by using a needle and a syringe. The "Bethesda System for Reporting Thyroid Cytopathology" is the system used to report whether the thyroid cytological specimen is benign or malignant. It can be divided into six categories:

Repeated FNAC is recommended for Category I, followed by clinical follow-up in Category II, repeat FNAC for Category III, and lobectomy for Category IV, near total-thyroidectomy/lobectomy for Category V, and near total thyroidectomy for Category VI. The risk of malignancy in a malignant FNAC report is 93.7% while for suspicious FNAC report, it is 18.9%.

Experts have not reached agreement on whether all pregnant women should be routinely screened for thyroid problems. But, if an underactive thyroid with or without symptoms is found during pregnancy it will be treated to lower the risk of pregnancy problems. An underactive thyroid without symptoms occurs in 2 to 3 in every 100 pregnancies. Women can request thyroid screening.

Iodine deficiency is treated by ingestion of iodine salts, such as found in food supplements. Mild cases may be treated by using iodized salt in daily food consumption, or drinking more milk, or eating egg yolks, and saltwater fish. For a salt and/or animal product restricted diet, sea vegetables (kelp, hijiki, dulse, nori (found in sushi)) may be incorporated regularly into a diet as a good source of iodine.

The recommended daily intake of iodine for adult women is 150–300 µg for maintenance of normal thyroid function; for men it is somewhat less at 150 µg.

However, too high iodine intake, for example due to overdosage of iodine supplements, can have toxic side effects. It can lead to hyperthyroidism and consequently high blood levels of thyroid hormones (hyperthyroxinemia). In case of extremely high single-dose iodine intake, typically a short-term suppression of thyroid function (Wolff–Chaikoff effect) occurs. Persons with pre-existing thyroid disease, elderly persons, fetuses and neonates, and patients with other risk factors are at a higher risk of experiencing iodine-induced thyroid abnormalities. In particular, in persons with goiter due to iodine deficiency or with altered thyroid function, a form of hyperthyroidism called Jod-Basedow phenomenon can be triggered even at small or single iodine dosages, for example as a side effect of administration of iodine-containing contrast agents. In some cases, excessive iodine contributes to a risk of autoimmune thyroid diseases (Hashimoto's thyroiditis and Graves' disease).

The diagnostic workup of a suspected iodine deficiency includes signs and symptoms as well as possible risk factors mentioned above. A 24-hour urine iodine collection is a useful medical test, as approximately 90% of ingested iodine is excreted in the urine. For the standardized 24-hour test, a 50 mg iodine load is given first, and 90% of this load is expected to be recovered in the urine of the following 24 hours. Recovery of less than 90% is taken to mean high retention, that is, iodine deficiency. The recovery may, however, be well less than 90% during pregnancy, and an intake of goitrogens can alter the test results.

If a 24-hour urine collection is not practical, a random urine iodine-to-creatinine ratio can alternatively be used. However, the 24-hour test is found to be more reliable.

A general idea of whether a deficiency exists can be determined through a functional iodine test in the form of an iodine skin test. In this test, the skin is painted with an iodine solution: if the iodine patch disappears quickly, this is taken as a sign of iodine deficiency. However, no accepted norms exist on the expected time interval for the patch to disappear, and in persons with dark skin color the disappeance of the patch may be difficult to assess. If a urine test is taken shortly after, the results may be altered due to the iodine absorbed previously in a skin test.

During pregnancy, women may want to see both an OB/GYN and an endocrinologist, a doctor who treats people with hormone problems. Levothyroxine is safe to use during pregnancy and necessary for the health of the baby. Women with Hashimoto's disease or an underactive thyroid who are taking levothyroxine before pregnancy may need a higher dose to maintain normal thyroid function. Clinicians may check thyroid function every 6 to 8 weeks during pregnancy. After delivery, hormone levels usually go back to the pre-pregnancy level.

Polar T syndrome is a condition found in polar explorers, caused by a reduction in levels of the thyroid hormone T. Its effects include forgetfulness, cognitive impairment and mood disturbances. It can exhibit itself in a fugue state known as the "Antarctic stare".

It is regarded as one of the contributory causes of winter-over syndrome.

Not smoking is a common suggestion in the literature. Apart from smoking cessation, there is little definitive research in this area. In addition to the selenium studies above, some recent research also is suggestive that statin use may assist.

Diagnosis of Harlequin syndrome is made when the individual has consistent signs and symptoms of the condition, therefore, it is made by clinical observation. In addition, a neurologist or primary care physician may require an MRI test to rule out similar disorders such as Horner's syndrome, Adie's syndrome, and Ross' syndrome. In an MRI, a radiologist may observe areas near brain or spinal cord for lesions, or any damage to the nerve endings. It is also important that the clinician rules out traumatic causes by performing autonomic function tests. Such tests includes the following: tilt table test, orthostatic blood pressure measurement, head-up test, valsalva maneuver, thermoregulatory sweat test, tendon reflex test, and electrocardiography (ECG). CT scan of the heart and lungs may also be performed to rule out a structural underlying lesion. The medical history of the individual should be carefully noted.

Various tests can be chosen depending on the presenting symptoms. Doctors may search for Thyroid peroxidase Antibodies (TPOAb) when a person has symptoms of hypothyroidism, or when a person will be started on a drug therapy associated with risks of developing hypothyroidism, such as lithium or Interferon alfa. This antibody is related to Hashimoto's thyroiditis and Graves' disease. If the person presents symptoms of hyperthyroidism, doctors are more likely to test for Thyroid stimulating hormone receptor Antibodies (TRAb), and monitor the effects of anti-thyroid therapy, also associated with Graves' disease.

Doctors may check Thyroglobulin Antibodies (TgAb) also, whenever a thyroglobulin test is performed to see if the antibody is interfering. TgAb may also be ordered in regular intervals after a person has been diagnosed with thyroid cancer, and just like TPOAb, it can be associated with Hashimoto’s thyroiditis.

Pregnant women who are positive for Hashimoto's thyroiditis may have decreased thyroid function or the gland may fail entirely. If a woman is TPOAb-positive, clinicians can inform her of the risks for themselves and their infants if they go untreated. "Thyroid peroxidase antibodies (TPOAb) are detected in 10% of pregnant women," which presents risks to those pregnancies. Women who have low thyroid function that has not been stabilized are at greater risk of having an infant with: low birth weight, neonatal respiratory distress, hydrocephalus, hypospadias, miscarriage, and preterm delivery. The embryo transplantion rate and successful pregnancy outcomes are improved when Hashimoto's is treated. Recommendations are to only treat pregnant women who are TPOAb-positive throughout the entirety of their pregnancies and to screen all pregnant women for thyroid levels. Close cooperation between the endocrinologist and obstetrician benefits the woman and the infant. The Endocrine Society recommends screening in pregnant women who are considered high-risk for thyroid autoimmune disease.

Thyroid peroxides antibodies testing is recommended for women who have ever been pregnant regardless of pregnancy outcome. "...[P]revious pregnancy plays a major role in development of autoimmune overt hypothyroidism in premenopausal women, and the number of previous pregnancies should be taken into account when evaluating the risk of hypothyroidism in a young women ["sic"]."

Graves' disease may present clinically with one of these characteristic signs:

- Rapid heart beat (80%)

- Diffuse palpable goiter with audible bruit (70%)

- Tremor (40%)

- Exophthalmos (protuberance of one or both eyes), periorbital edema (25%)

- Fatigue (70%), weight loss (60%) with increased appetite in young people and poor appetite in the elderly, and other symptoms of hyperthyroidism/thyrotoxicosis

- Heat intolerance (55%)

- Tremulousness (55%)

- Palpitations (50%)

Two signs are truly 'diagnostic' of Graves' disease ("i.e.," not seen in other hyperthyroid conditions): exophthalmos and nonpitting edema (pretibial myxedema). Goiter is an enlarged thyroid gland and is of the diffuse type ("i.e.," spread throughout the gland). Diffuse goiter may be seen with other causes of hyperthyroidism, although Graves' disease is the most common cause of diffuse goiter. A large goiter will be visible to the naked eye, but a small one (mild enlargement of the gland) may be detectable only by physical examination. Occasionally, goiter is not clinically detectable, but may be seen only with computed tomography or ultrasound examination of the thyroid.

Another sign of Graves' disease is hyperthyroidism, "i.e.", overproduction of the thyroid hormones T3 and T4. Normal thyroid levels are also seen, and occasionally also hypothyroidism, which may assist in causing goiter (though it is not the cause of the Graves' disease). Hyperthyroidism in Graves' disease is confirmed, as with any other cause of hyperthyroidism, by measuring elevated blood levels of free (unbound) T3 and T4.

Other useful laboratory measurements in Graves' disease include thyroid-stimulating hormone (TSH, usually undetectable in Graves' disease due to negative feedback from the elevated T3 and T4), and protein-bound iodine (elevated). Serologically detected thyroid-stimulating antibodies, radioactive iodine (RAI) uptake, or thyroid ultrasound with Doppler all can independently confirm a diagnosis of Grave's disease.

Biopsy to obtain histiological testing is not normally required, but may be obtained if thyroidectomy is performed.

The goiter in Graves' disease is often not nodular, but thyroid nodules are also common. Differentiating common forms of hyperthyroidism such as Graves' disease, single thyroid adenoma, and toxic multinodular goiter is important to determine proper treatment. The differentiation among these entities has advanced, as imaging and biochemical tests have improved. Measuring TSH-receptor antibodies with the h-TBII assay has been proven efficient and was the most practical approach found in one study.

Graves' ophthalmopathy is diagnosed clinically by the presenting ocular signs and symptoms, but positive tests for antibodies (anti-thyroglobulin, anti-microsomal and anti-thyrotropin receptor) and abnormalities in thyroid hormones level (T3, T4, and TSH) help in supporting the diagnosis.

Orbital imaging is an interesting tool for the diagnosis of Graves' ophthalmopathy and is useful in monitoring patients for progression of the disease. It is, however, not warranted when the diagnosis can be established clinically. Ultrasonography may detect early Graves' orbitopathy in patients without clinical orbital findings. It is less reliable than the CT scan and magnetic resonance imaging (MRI), however, to assess the extraocular muscle involvement at the orbital apex, which may lead to blindness. Thus, CT scan or MRI is necessary when optic nerve involvement is suspected. On neuroimaging, the most characteristic findings are thick extraocular muscles with tendon sparing, usually bilateral, and proptosis.