Pneumomediastinum is uncommon and occurs when air leaks into the mediastinum. The diagnosis can be confirmed via chest X-ray showing a radiolucent outline around the heart and mediastinum or via CT scanning of the thorax.

If the symptoms are severe enough, treatment may be needed. These range from medical management over mechanical ventilation (both continuous positive airway pressure (CPAP), or bi-level positive airway pressure (BiPAP) to tracheal stenting and surgery.

Surgical techniques include aortopexy, tracheopexy, tracheobronchoplasty, and tracheostomy. The role of the nebulised recombinant human deoxyribonuclease (rhDNase) remains inconclusive.

Pulmonary aspiration resulting in pneumonia, in some patients, particularly those with physical limitations, can be fatal.

The lungs are normally protected against aspiration by a series of "protective reflexes" such as coughing and swallowing. Significant aspiration can only occur if the protective reflexes are absent or severely diminished (in neurological disease, coma, drug overdose, sedation or general anesthesia). In intensive care, sitting patients up reduces the risk of pulmonary aspiration and ventilator-associated pneumonia.

Measures to prevent aspiration depend on the situation and the patient. In patients at imminent risk of aspiration, tracheal intubation by a trained health professional provides the best protection. A simpler intervention that can be implemented is to lay the patient on their side in the recovery position (as taught in first aid and CPR classes), so that any vomitus produced by the patient will drain out their mouth instead of back down their pharynx. Some anesthetists will use sodium citrate to neutralize the stomach's low pH and metoclopramide or domperidone (pro-kinetic agents) to empty the stomach.

People with chronic neurological disorders, for example, after a stroke, are less likely to aspirate thickened fluids.

The location of abscesses caused by aspiration depends on the position one is in. If one is sitting or standing up, the aspirate ends up in the posterior basal segment of the right lower lobe. If one is on one's back, it goes to the superior segment of the right lower lobe. If one is lying on the right side, it goes to the posterior segment of the right upper lobe, or the posterior basal segment of the right upper lobe. If one is lying on the left, it goes to the lingula.

Diagnosis is conducted according to the severity of the symptoms. Initially pulmonary function tests are administered. These tests include the lungs' capability of air intake and outtake, and gas flow of oxygen and carbon dioxide between the body and environment. Following these function tests a CT scan or bronchoscopy will be ordered. The results to the scan and bronchoscopy will display the status of the rare condition. A mild case of tracheobronchomalacia would be if the patient's trachea condenses 50% of its normal space when exhaling. Moderate tracheobronchomalacia would be 25% of the normal trachea space constricting and a severe case would be if the walls touch each other.

For children less than 1 year, the American Heart Association recommends performing cycles of 5 back blows (or slaps) followed by 5 chest compressions. These cycles of 5 back blows then 5 chest compressions are repeated until the object comes out of the infant's airway or until the infant becomes unresponsive. If the infant becomes unresponsive, the American Heart Association recommends starting CPR. The reason that abdominal thrusts are not recommended in children less than 1 year is because they can cause liver damage.

To properly treat a patient with tracheobronchomalacia, the subtype must be determined (primary or secondary). After the type is named, the cause must be identified, whether it is from genetics, a trauma accident, or chronic tracheal illness. If a trauma case or chronic tracheal illnesses were the cause, the first steps of treatment would be to fix or help these underlying issues. If the cause is genetic or the previous underlying issues could not be fixed, other treatments would be assessed. More severe treatments include silicone stenting to prevent tracheal constriction, surgery to strengthen or attempt to rebuild the walls, continuous positive airway pressure that has a machine blow small amounts of air into the trachea to keep it open (mainly at night), or a tracheostomy, which is surgically put into your neck that leads to your trachea to help with breathing. People with tracheobronchomalacia who do not experience symptoms do not need treatment and are often undiagnosed.

The American Heart Association recommends chest thrusts rather than abdominal thrusts for pregnant or obese persons who are choking.

Chest thrusts are performed in a similar to the abdominal thrusts, but with a change in hand placement of the rescuer. The hands are placed on the lower part of the choking victim's chest, at the base of the breastbone or sternum, rather than over the middle of the abdomen, as in traditional abdominal thrusts. Strong inward thrusts are then applied.

Significant cases of subcutaneous emphysema are easy to diagnose because of the characteristic signs of the condition. In some cases, the signs are subtle, making diagnosis more difficult. Medical imaging is used to diagnose the condition or confirm a diagnosis made using clinical signs. On a chest radiograph, subcutaneous emphysema may be seen as radiolucent striations in the pattern expected from the pectoralis major muscle group. Air in the subcutaneous tissues may interfere with radiography of the chest, potentially obscuring serious conditions such as pneumothorax. It can also reduce the effectiveness of chest ultrasound. On the other hand, since subcutaneous emphysema may become apparent in chest X-rays before a pneumothorax does, its presence may be used to infer that of the latter injury. Subcutaneous emphysema can also be seen in CT scans, with the air pockets appearing as dark areas. CT scanning is so sensitive that it commonly makes it possible to find the exact spot from which air is entering the soft tissues. In 1994, M.T. Macklin and C.C. Macklin published further insights into the pathophysiology of spontaneous Macklin's Syndrome occurring from a severe asthmatic attack.

The presence of subcutaneous emphysema in a person who appears quite ill and febrile after bout of vomiting followed by left chest pain is very suggestive of the diagnosis of Boerhaave's syndrome, which is a life-threatening emergency caused by rupture of the distal esophagus.

Respiratory diseases may be investigated by performing one or more of the following tests

- Biopsy of the lung or pleura

- Blood test

- Bronchoscopy

- Chest x-ray

- Computed tomography scan, including high-resolution computed tomography

- Culture of microorganisms from secretions such as sputum

- Ultrasound scanning can be useful to detect fluid such as pleural effusion

- Pulmonary function test

- Ventilation—perfusion scan

The tissues in the mediastinum will slowly resorb the air in the cavity so most pneumomediastinums are treated conservatively. Breathing high flow oxygen will increase the absorption of the air.

If the air is under pressure and compressing the heart, a needle may be inserted into the cavity, releasing the air.

Surgery may be needed to repair the hole in the trachea, esophagus or bowel.

If there is lung collapse, it is imperative the affected individual lies on the side of the collapse, although painful, this allows full inflation of the unaffected lung.

Respiratory disease is a common and significant cause of illness and death around the world. In the US, approximately 1 billion "common colds" occur each year. A study found that in 2010, there were approximately 6.8 million emergency department visits for respiratory disorders in the U.S. for patients under the age of 18. In 2012, respiratory conditions were the most frequent reasons for hospital stays among children.

In the UK, approximately 1 in 7 individuals are affected by some form of chronic lung disease, most commonly chronic obstructive pulmonary disease, which includes asthma, chronic bronchitis and emphysema.

Respiratory diseases (including lung cancer) are responsible for over 10% of hospitalizations and over 16% of deaths in Canada.

In 2011, respiratory disease with ventilator support accounted for 93.3% of ICU utilization in the United States.

If the person is awake and able to breathe often all that is requires is providing extra oxygen while the operating room is prepared for bronchoscopy.

If a children less than one and is unable to breathe at all then five back blows followed by five chest thrusts should be done. In children over the age of one abdominal thrusts are recommended.

If this is not effective than bag mask ventilation is recommended. Next laryngoscopy can be tried to look and see if the foreign body can be removed. If the above is not effective than intubation or cricothyrotomy can be tried.

The optimal management of laryngotracheal stenosis is not well defined, depending mainly on the type of the stenosis.

General treatment options include

1. Tracheal dilation using rigid bronchoscope

2. Laser surgery and endoluminal stenting

3. Tracheal resection and laryngotracheal reconstructionr

Tracheal is used to temporarily enlarge the airway. The effect of dilation typically lasts from a few days to 6 months. Several studies have shown that as a result of mechanical dilation (used alone) may occur a high mortality rate and a rate of recurrence of stenosis higher than 90%.

Thus, many authors treat the stenosis by endoscopic excision with laser (commonly either the carbon dioxide or the neodymium: yttrium aluminum garnet laser) and then by using bronchoscopic dilatation and prolonged stenting with a T-tube (generally in silicone).

There are differing opinions on treating with laser surgery.

In very experienced surgery centers, tracheal resection and reconstruction (anastomosis complete end-to-end with or without laryngotracheal temporary stent to prevent airway collapse) is currently the best alternative to completely cure the stenosis and allows to obtain good results. Therefore, it can be considered the gold standard treatment and is suitable for almost all patients.

The narrowed part of the trachea will be cut off and the cut ends of the trachea sewn together with sutures. For stenosis of length greater than 5 cm a stent may be required to join the sections.

Late June or early July 2010, a new potential treatment was trialed at Great Ormond Street Hospital in London, where Ciaran Finn-Lynch (aged 11) received a transplanted trachea which had been injected with stem cells harvested from his own bone marrow. The use of Ciaran's stem cells was hoped to prevent his immune system from rejecting the transplant, but there remain doubts about the operation's success, and several later attempts at similar surgery have been unsuccessful.

Laryngotracheal stenosis is an umbrella term for a wide and heterogeneous group of very rare conditions. The population incidence of adult post-intubation laryngotracheal stenosis which is the commonest benign sub-type of this condition is approximately 1 in 200,000 adults per year. The main causes of adult laryngotracheal stenosis are:

There are three types of tracheomalacia:

- Type 1—congenital, sometimes associated with tracheoesophageal fistula or esophageal atresia

- Type 2—extrinsic compression sometimes due to vascular rings

- Type 3—acquired due to chronic infection or prolonged intubation or inflammatory conditions like relapsing polychondritis

Rapid diagnosis and treatment are important in the care of TBI; if the injury is not diagnosed shortly after the injury, the risk of complications is higher. Bronchoscopy is the most effective method to diagnose, locate, and determine the severity of TBI, and it is usually the only method that allows a definitive diagnosis. Diagnosis with a flexible bronchoscope, which allows the injury to be visualized directly, is the fastest and most reliable technique. In people with TBI, bronchoscopy may reveal that the airway is torn, or that the airways are blocked by blood, or that a bronchus has collapsed, obscuring more distal (lower) bronchi from view.

Chest x-ray is the initial imaging technique used to diagnose TBI. The film may not have any signs in an otherwise asymptomatic patient. Indications of TBI seen on radiographs include deformity in the trachea or a defect in the tracheal wall. Radiography may also show cervical emphysema, air in the tissues of the neck. X-rays may also show accompanying injuries and signs such as fractures and subcutaneous emphysema. If subcutaneous emphysema occurs and the hyoid bone appears in an X-ray to be sitting unusually high in the throat, it may be an indication that the trachea has been severed. TBI is also suspected if an endotracheal tube appears in an X-ray to be out of place, or if its cuff appears to be more full than normal or to protrude through a tear in the airway. If a bronchus is torn all the way around, the lung may collapse outward toward the chest wall (rather than inward, as it usually does in pneumothorax) because it loses the attachment to the bronchus which normally holds it toward the center. In a person lying face-up, the lung collapses toward the diaphragm and the back. This sign, described in 1969, is called fallen lung sign and is pathognomonic of TBI (that is, it is diagnostic for TBI because it does not occur in other conditions); however it occurs only rarely. In as many as one in five cases, people with blunt trauma and TBI have no signs of the injury on chest X-ray. CT scanning detects over 90% of TBI resulting from blunt trauma, but neither X-ray nor CT are a replacement for bronchoscopy.

At least 30% of TBI are not discovered at first; this number may be as high as 50%. In about 10% of cases, TBI has no specific signs either clinically or on chest radiography, and its detection may be further complicated by concurrent injuries, since TBI tends to occur after high-energy accidents. Weeks or months may go by before the injury is diagnosed, even though the injury is better known than it was in the past.

A 2014 systematic review of clinical trials does not support using routine rapid viral testing to decrease antibiotic use for children in emergency departments. It is unclear if rapid viral testing in the emergency department for children with acute febrile respiratory infections reduces the rates of antibiotic use, blood testing, or urine testing. The relative risk reduction of chest x-ray utilization in children screened with rapid viral testing is 77% compared with controls. In 2013 researchers developed a breath tester that can promptly diagnose lung infections.

Chest radiography is the preferred means of initial diagnosis for hemothorax. Upright radiography is preferred but supine films may be taken when upright radiography is not feasible due to the clinical situation. Tube thoracostomy may be done prior to imaging when patients have sustained blunt or penetrating thoracic trauma and display unstable hemodynamics, have respiratory failure with absent or decreased breath sounds, show tracheal deviation, or have serious penetrating injuries. In upright radiography, hemothorax is suggested by blunting of the costophrenic angle or partial or complete opacification of the hemithorax, in which the lateral side of the chest appears bright and the lung appears pushed away toward the center; the air-filled lung normally appears as a dark space on radiographic film. In the case of a small hemothorax, several hundred milliliters of blood can be hidden by the diaphragm and abdominal viscera. In supine patients, signs of hemothorax may also be subtle on radiographic film, because the blood will layer in the pleural space, and can be seen as a haziness in one half of the thorax relative to the other side.

Ultrasonography is also used for detection of hemothorax and other pleural effusions, particularly in the critical care and trauma settings, because it provides rapid, reliable results in order to make a diagnosis in an emergency situation. Computed tomography (CT or CAT) scans can detect much smaller amounts of fluid than chest radiography, but computed tomography is not a primary method of diagnosis within the trauma setting, due to the time required for imaging, the requirement that a patient remain supine, and the need to transport a critically ill patient to the scanner.

Subcutaneous emphysema is usually benign. Most of the time, SCE itself does not need treatment (though the conditions from which it results may); however, if the amount of air is large, it can interfere with breathing and be uncomfortable. It occasionally progresses to a state "Massive Subcutaneous Emphysema" which is quite uncomfortable and requires surgical drainage. When the amount of air pushed out of the airways or lung becomes massive, usually due to positive pressure ventilation, the eyelids swell so much that the patient cannot see. Also the pressure of the air may impede the blood flow to the areolae of the breast and skin of the scrotum or labia. This can lead to necrosis of the skin in these areas. The latter are urgent situations requiring rapid, adequate decompression. Severe cases can compress the trachea and do require treatment.

In severe cases of subcutaneous emphysema, catheters can be placed in the subcutaneous tissue to release the air. Small cuts, or "blow holes", may be made in the skin to release the gas. When subcutaneous emphysema occurs due to pneumothorax, a chest tube is frequently used to control the latter; this eliminates the source of the air entering the subcutaneous space. If the volume of subcutaneous air is increasing, it may be that the chest tube is not removing air rapidly enough, so it may be replaced with a larger one. Suction may also be applied to the tube to remove air faster. The progression of the condition can be monitored by marking the boundaries with a special pencil for marking on skin.

Since treatment usually involves dealing with the underlying condition, cases of spontaneous subcutaneous emphysema may require nothing more than bed rest, medication to control pain, and perhaps supplemental oxygen. Breathing oxygen may help the body to absorb the subcutaneous air more quickly.

Treatment depends on the underlying cause. Treatments include iced saline, and topical vasoconstrictors such as adrenalin or vasopressin. Selective bronchial intubation can be used to collapse the lung that is bleeding. Also, endobronchial tamponade can be used. Laser photocoagulation can be used to stop bleeding during bronchoscopy. Angiography of bronchial arteries can be performed to locate the bleeding, and it can often be embolized. Surgical option is usually the last resort, and can involve, removal of a lung lobe or removal of the entire lung. Non–small-cell lung cancer can also be treated with erlotinib or gefitinib. Cough suppressants can increase the risk of choking.

Vehicle occupants who wear seat belts have a lower incidence of TBI after a motor vehicle accident. However, if the strap is situated across the front of the neck (instead of the chest), this increases the risk of tracheal injury. Design of medical instruments can be modified to prevent iatrogenic TBI, and medical practitioners can use techniques that reduce the risk of injury with procedures such as tracheotomy.

To prevent an TIF, intubation time should be limited to less than 2 weeks and proper techniques should be used when performing tracheotomies. The occurrence of an TIF can be reduced by using more flexible and blunt tracheostomy tubes and insuring that the tubes are properly aligned in the patients. Placing the tracheostomy between the second and third tracheal rings can minimize the risk of an TIF. Repetitive head movements, especially, hyperextension of the neck should be avoided as since this movement results in contact between the innominate artery and the underside of the tube.

A Saber-sheath trachea is a trachea that has an abnormal shape caused by chronic obstructive pulmonary disease. The posterior area of the trachea increases in diameter while the lateral measurement decreases.

TIF is a rare condition with a .7% frequency, and an mortality rate approaching 100% without surgical intervention. Immediate diagnosis and intervention of an TIF is critical for the surgical intervention success. 25-30% of TIF patients who reach the operating room survive. Recently, the incidence of TIF may have declined due to advances in tracheostomy tube technology and the introduction of the bedside percutaneous dilatational tracheostomy (PDT).