In the United States, chemical eye injuries most commonly occur among working-age adults. A 2016 analysis of emergency department visits from 2010-2013 reported over 36,000 visits annually for chemical burns to the eye, with a median age at presentation of 32 years. By individual year of age, 1- and 2-year-old children have the highest incidence of these injuries, with rates approximately 50% higher than the highest-risk adult group (25 years), and 13 times higher than the rate among 7-year-olds. Further research identified laundry detergent pods as a major source of injury among small children.

Chemical eye injury or chemical burns to the eye are due to either an acidic or alkali substance getting in the eye. Alkalis are typically worse than acidic burns. Mild burns will produce conjunctivitis while more severe burns may cause the cornea to turn white. Litmus paper is an easy way to rule out the diagnosis by verifying that the pH is within the normal range of 7.0—7.2. Large volumes of irrigation is the treatment of choice and should continue until the pH is 6—8. Local anaesthetic eye drops can be used to decrease the pain.

Eating certain products and using special routines may help recovery.

Multiple complications are known to occur following eye injury: corneal scarring, hyphema, iridodialysis, post-traumatic glaucoma, uveitis cataract, vitreous hemorrhage and retinal detachment. The complications risk is high with retinal tears, penetrating injuries and severe blunt trauma.

Photokeratitis can be prevented by using sunglasses or eye protection that transmits 5–10% of visible light and absorbs almost all UV rays. Additionally, these glasses should have large lenses and side shields to avoid incidental light exposure. Sunglasses should always be worn, even when the sky is overcast, as UV rays can pass through clouds.

The Inuit, Yupik, and other Arctic peoples carved snow goggles from materials such as driftwood or caribou antlers to help prevent snow blindness. Curved to fit the user's face with a large groove cut in the back to allow for the nose, the goggles allowed in a small amount of light through a long thin slit cut along their length. The goggles were held to the head by a cord made of caribou sinew.

In the event of missing sunglass lenses, emergency lenses can be made by cutting slits in dark fabric or tape folded back onto itself. The "SAS Survival Guide" recommends blackening the skin underneath the eyes with charcoal (as the ancient Egyptians did) to avoid any further reflection.

Methods to prevent intraoperative corneal injuries include

- simple manual closure of the eyelids

- holding the eyelids shut with tape or a general purpose adhesive dressing

- use of a specially designed eyelid occlusion dressing

- use of eye ointment (although this is controversial, see below)

- bio-occlusive dressings

- suture tarsorrhaphy

However, none of the protective strategies are completely effective; vigilance is always required i.e. the eyes need to be inspected regularly throughout surgery to check they are closed.

The pain may be temporarily alleviated with anaesthetic eye drops for the examination; however, they are not used for continued treatment, as anaesthesia of the eye interferes with corneal healing, and may lead to corneal ulceration and even loss of the eye. Cool, wet compresses over the eyes and artificial tears may help local symptoms when the feeling returns. Nonsteroidal anti-inflammatory drug (NSAID) eyedrops are widely used to lessen inflammation and eye pain, but have not been proven in rigorous trials. Systemic (oral) pain medication is given if discomfort is severe. Healing is usually rapid (24–72 hours) if the injury source is removed. Further injury should be avoided by isolation in a dark room, removing contact lenses, not rubbing the eyes, and wearing sunglasses until the symptoms improve.

Some of the adverse outcomes associated with intra-operative injuries include:

- Increased length of stay. This is due to ophthalmology consults required, associated infections and treatment.

- Increased costs. This is due to increased length of stay, cost of treating the complications.

- Pain and discomfort for the patient. Corneal abrasions are extremely painful for the patient and the treatment consists of drops and ointments applied in the eye which may cause further discomfort for the patient.

NK is diagnosed on the basis of the patient's medical history and a careful examination of the eye and surrounding area.

With regard to the patient's medical history, special attention should be paid to any herpes virus infections and possible surgeries on the cornea, trauma, abuse of anaesthetics or chronic topical treatments, chemical burns or, use of contact lenses. It is also necessary to investigate the possible presence of diabetes or other systemic diseases such as multiple sclerosis.

The clinical examination is usually performed through a series of assessments and tools:

- General examination of cranial nerves, to determine the presence of nerve damage.

- Eye examinations:

1. Complete eye examination: examination of the eyelids, blink rate, presence of inflammatory reactions and secretions, corneal epithelial alterations.

2. Corneal sensitivity test: performed by placing a cotton wad or cotton thread in contact with the corneal surface: this only allows to determine whether corneal sensitivity is normal, reduced or absent; or using an esthesiometer that allows to assess corneal sensitivity.

3. Tear film function test, such as Schirmer's test, and tear film break-up time.

4. Fluorescein eye stain test, which shows any damage to the corneal and conjunctival epithelium

The presence of an open globe injuries may be determined by clinical examination and CT. However, full globe exploration with 360-degree removal of the conjunctiva (periotomy), separation of the rectus muscles, and subsequent examination of the sclera remains the most effective way to determine whether or not the globe has been injured. During exploratory surgery, foreign debris may be removed with microsurgical tools by inspection under the operating room microscope. Globe lacerations are typically repaired as far posteriorly as possible to prevent any further deficits in visual acuity. Lacerations posterior to the exposed area are not sutured; attempts to seal these injuries often results in the extrusion of intraocular components. Healing of these injuries occurs naturally by scarring of dorsal orbital fat to the sclera. If a clinically significant increase in intraocular pressure is detected with orbital compartment syndrome, the ophthalmologist may perform an emergency canthotomy on the lateral canthus. Canalicular injuries, as well as lid lacerations, are also commonly repaired in the military hospital setting. Suturing the laceration after the removal of foreign bodies depends on the location of global fissure: 10-0 nylon with cyanoacrylate glue is commonly used on the cornea, and processed human pericardium may be employed if it is surgically available. Globe closure of the limbus and sclera requires 9-0 and 8-0 nylon, respectively.

If damage to the globe is irreparable, the ophthalmologist may conduct a primary enucleation, evisceration (ophthalmology), or exenteration in the combat hospital. 14% of globe injuries sustained during Operation Iraqi Freedom have required enucleation. Implantation of an oculoplastic silicone sphere or similar device commonly follows these procedures.

Diagnosis is done by direct observation under magnified view of slit lamp revealing the ulcer on the cornea. The use of fluorescein stain, which is taken up by exposed corneal stroma and appears green, helps in defining the margins of the corneal ulcer, and can reveal additional details of the surrounding epithelium. Herpes simplex ulcers show a typical dendritic pattern of staining. Rose-Bengal dye is also used for supra-vital staining purposes, but it may be very irritating to the eyes. In descemetoceles, the Descemet's membrane will bulge forward and after staining will appear as a dark circle with a green boundary, because it does not absorb the stain. Doing a corneal scraping and examining under the microscope with stains like Gram's and KOH preparation may reveal the bacteria and fungi respectively. Microbiological culture tests may be necessary to isolate the causative organisms for some cases. Other tests that may be necessary include a Schirmer's test for keratoconjunctivitis sicca and an analysis of facial nerve function for facial nerve paralysis.

Post-operative care for patients with blast-related ocular trauma occurs in tertiary care facilities. Patients with closed globe injuries require observation and follow-up examination with an optometrist, including slit lamp microscope and dilated fundus inspection. Those who have been treated for open-globe repairs often experience a delay of post-operative treatment that ranges from 10–14 days after injury. This period is due to the treatment of other life-threatening injuries, as well as the necessity for accurate estimation of visual acuity outside of inflammation due to injury and surgical intervention.

In patients with facial burns, exposure keratopathy, or chronic epiphora, an ophthalmologist may suggest eyelid reconstruction surgery. Depending on the severity of physical trauma sustained, surgical realignment of the extraocular muscles may relieve strabismus. Realignment of the extraocular muscles is also indicated in chronic diplopia that occurs within 20-degrees of the visual field. All patients that have sustained a traumatic brain injury in the absence of ocular trauma are still recommended to obtain examination by an optometrist. Outside of the treatment facility, these patients must monitor any signs of late-onset ocular pathologies secondary to the bTBI, including decreased visual/reading ability and speed, photophobia, blurred vision, reduced accommodation abilities, and headaches.

Intraocular pressure should be measured as part of the routine eye examination.

It is usually only elevated by iridocyclitis or acute-closure glaucoma, but not by relatively benign conditions.

In iritis and traumatic perforating ocular injuries, the intraocular pressure is usually low.

Dry eyes can usually be diagnosed by the symptoms alone. Tests can determine both the quantity and the quality of the tears. A slit lamp examination can be performed to diagnose dry eyes and to document any damage to the eye.

A Schirmer's test can measure the amount of moisture bathing the eye. This test is useful for determining the severity of the condition. A five-minute Schirmer's test with and without anesthesia using a Whatman #41 filter paper 5 mm wide by 35 mm long is performed. For this test, wetting under 5 mm with or without anesthesia is considered diagnostic for dry eyes.

If the results for the Schirmer's test are abnormal, a Schirmer II test can be performed to measure reflex secretion. In this test, the nasal mucosa is irritated with a cotton-tipped applicator, after which tear production is measured with a Whatman #41 filter paper. For this test, wetting under 15 mm after five minutes is considered abnormal.

A tear breakup time (TBUT) test measures the time it takes for tears to break up in the eye. The tear breakup time can be determined after placing a drop of fluorescein in the cul-de-sac.

A tear protein analysis test measures the lysozyme contained within tears. In tears, lysozyme accounts for approximately 20 to 40 percent of total protein content.

A lactoferrin analysis test provides good correlation with other tests.

The presence of the recently described molecule Ap4A, naturally occurring in tears, is abnormally high in different states of ocular dryness. This molecule can be quantified biochemically simply by taking a tear sample with a plain Schirmer test. Utilizing this technique it is possible to determine the concentrations of Ap4A in the tears of patients and in such way diagnose objectively if the samples are indicative of dry eye.

The Tear Osmolarity Test has been proposed as a test for dry eye disease. Tear osmolarity may be a more sensitive method of diagnosing and grading the severity of dry eye compared to corneal and conjunctival staining, tear break-up time, Schirmer test, and meibomian gland grading. Others have recently questioned the utility of tear osmolarity in monitoring dry eye treatment.

According to Mackie's classification, neurotrophic keratitis can be divided into three stages based on severity:

1. "Stage I:" characterized by alterations of the corneal epithelium, which is dry and opaque, with superficial punctate keratopathy and corneal oedema. Long-lasting neurotrophic keratitis may also cause hyperplasia of the epithelium, stromal scarring and neovascularization of the cornea.

2. "Stage II:" characterized by development of epithelial defects, often in the area near the centre of the cornea.

3. "Stage III:" characterized by ulcers of the cornea accompanied by stromal oedema and/or melting that may result in corneal perforation.

In an eye with iridocyclitis, (inflammation of both the iris and ciliary body), the involved pupil will be smaller than the uninvolved, due to reflex muscle spasm of the sphincter muscle of the iris.

Generally, conjunctivitis does not affect the pupils.

With acute angle-closure glaucoma, the pupil is generally fixed in mid-position, oval, and responds sluggishly to light, if at all.

Shallow anterior chamber depth may indicate a predisposition to one form of glaucoma (narrow angle) but requires slit-lamp examination or other special techniques to determine it.

In the presence of a "red eye", a shallow anterior chamber may indicate acute glaucoma, which requires immediate attention.

There is no way to prevent keratoconjunctivitis sicca. Complications can be prevented by use of wetting and lubricating drops and ointments.

Due to the different underlying causes, proper diagnosis, treatment, and prognosis can only be determined by an eye care professional. Punctate epithelial erosions may be treated with artificial tears. In some disorders, topical antibiotic is added to the treatment. Patients should discontinue contact lens wear until recovery.

Generally speaking, people diagnosed with photic retinopathy recover visual acuity completely within two months, though more severe cases may take longer, or not see complete recovery at all.

Topical antibiotics are used at hourly intervals to treat infectious corneal ulcers. Cycloplegic eye drops are applied to give rest to the eye. Pain medications are given as needed. Loose epithelium and ulcer base can be scraped off and sent for culture sensitivity studies to find out the pathogenic organism. This helps in choosing appropriate antibiotics. Complete healing takes anywhere from about a few weeks to several months.

Refractory corneal ulcers can take a long time to heal, sometimes months. In case of progressive or non-healing ulcers, surgical intervention by an ophthalmologist with corneal transplantation may be required to save the eye. In all corneal ulcers it is important to rule out predisposing factors like diabetes mellitus and immunodeficiency.

Photic retinopathy generally goes away on its own over time, but there is no specific treatment known to be reliable for speeding recovery. One path sometimes attempted, which has unclear results, is to treat the initial macular edema with corticosteroids.

Diagnosis is clinical, seeking a history of eye injury. An important differential diagnosis is Vogt-Koyanagi-Harada syndrome (VKH), which is thought to have the same pathogenesis, without a history of surgery or penetrating eye injury.

Still experimental, skin tests with soluble extracts of human or bovine uveal tissue are said to elicit delayed hypersensitivity responses in these patients. Additionally, circulating antibodies to uveal antigens have been found in patients with SO and VKH, as well as those with long-standing uveitis, making this a less than specific assay for SO and VKH.

In advanced stages, corneal neovascularization can threaten eyesight, which is why routine (annual) eye exams are recommended for contact lens patients.

Because SO is so rarely encountered following eye injury, even when the injured eye is retained, the first choice of treatment may not be enucleation or evisceration, especially if there is a chance that the injured eye may regain some function. Additionally, with current advanced surgical techniques, many eyes once considered nonviable now have a fair prognosis.

However, only if the injured eye has completely lost its vision and has no potential for any visual recovery, prevention of SO is done by enucleation of the injured eye preferably within the first 2 weeks of injury. Evisceration—the removal of the contents of the globe while leaving the sclera and extraocular muscles intact—is easier to perform, offers long-term orbital stability, and is more aesthetically pleasing, i.e., a greater measure of movement of the prosthesis and thus a more natural appearance. There is concern, however, that evisceration may lead to a higher incidence of SO compared to enucleation. Several retrospective studies involving over 3000 eviscerations, however, have failed to identify a single case of SO.

Once SO is developed, Immunosuppressive therapy is the mainstay of treatment. When initiated promptly following injury, it is effective in controlling the inflammation and improving the prognosis. Mild cases may be treated with local application of corticosteroids and pupillary dilators. More severe or progressive cases require high-dose systemic corticosteroids for months to years. Patients who become resistant to corticosteroids or develop side effects of long-term corticosteroid therapy (osteoporosis and pathologic fractures, mental status changes, etc.), may be candidates for therapy with chlorambucil, cyclophosphamide, or ciclosporin.

Unless there is actual trauma to the eye itself (see below), extensive medical attention is generally not needed.

Applying an ice pack will keep down swelling and reduce internal bleeding by constricting the capillaries. Additionally, analgesic drugs (painkillers) can be administered to relieve pain.

An anecdotal remedy for a black eye involves the administering of raw meat to treat the condition - Research on this treatment has yet to find any evidence of this treatment being effective.