Links between maternal smoking and TDS are tenuous, but there are stronger associations between maternal alcohol consumption and incidences of cryptorchidism in sons. Smoking does however affect the growth of a fetus, and low birth weight is shown to increase the likelihood of all the disorders encompassed by TDS. Maternal obesity, resulting in gestational diabetes, has also been shown to be a risk factor for impaired testes development and TDS symptoms in sons.

Exposure of a male fetus to substances that disrupt hormone systems, particularly chemicals that inhibit the action of androgens (male sex hormones) during the development of the reproductive system, has been shown to cause many of the characteristic TDS disorders. These include environmental estrogens and anti-androgens found in food and water sources that have been contaminated with synthetic hormones and pesticides used in agriculture. In historical cases, medicines given to pregnant women, like diethylstilbestrol (DES), have caused many of the features of TDS in fetuses exposed to this chemical during gestation. The impact of environmental chemicals is well documented in animal models. If a substance affects Sertoli and Leydig cell differentiation (a common feature of TDS disorders) at an early developmental stage, germ cell growth and testosterone production will be impaired. These processes are essential for testes descent and genitalia development, meaning that genital abnormalities like cryptorchidism or hypospadias may be present from birth, and fertility problems and TGCC become apparent during adult life. Severity or number of disorders may therefore be dependent on the timing of the environmental exposure. Environmental factors can act directly, or via epigenetic mechanisms, and it is likely that a genetic susceptibility augmented by environmental factors is the primary cause of TDS.

Pre-testicular factors refer to conditions that impede adequate support of the testes and include situations of poor hormonal support and poor general health including:

- Hypogonadotropic hypogonadism due to various causes

- Obesity increases the risk of hypogonadotropic hypogonadism. Animal models indicate that obesity causes leptin insensitivity in the hypothalamus, leading to decreased Kiss1 expression, which, in turn, alters the release of gonadotropin-releasing hormone (GnRH).

- Undiagnosed and untreated coeliac disease (CD). Coeliac men may have reversible infertility. Nevertheless, CD can present with several non-gastrointestinal symptoms that can involve nearly any organ system, even in the absence of gastrointestinal symptoms. Thus, the diagnosis may be missed, leading to a risk of long-term complications. In men, CD can reduce semen quality and cause immature secondary sex characteristics, hypogonadism and hyperprolactinaemia, which causes impotence and loss of libido. The giving of gluten free diet and correction of deficient dietary elements can lead to a return of fertility. It is likely that an effective evaluation for infertility would best include assessment for underlying celiac disease, both in men and women.

- Drugs, alcohol

- Strenuous riding (bicycle riding, horseback riding)

- Medications, including those that affect spermatogenesis such as chemotherapy, anabolic steroids, cimetidine, spironolactone; those that decrease FSH levels such as phenytoin; those that decrease sperm motility such as sulfasalazine and nitrofurantoin

- Genetic abnormalities such as a Robertsonian translocation

There is increasing evidence that the harmful products of tobacco smoking may damage the testicles and kill sperm, but their effect on male fertility is not clear. Some governments require manufacturers to put warnings on packets. Smoking tobacco increases intake of cadmium, because the tobacco plant absorbs the metal. Cadmium, being chemically similar to zinc, may replace zinc in the DNA polymerase, which plays a critical role in sperm production. Zinc replaced by cadmium in DNA polymerase can be particularly damaging to the testes.

The human breast cancer susceptibility gene 2 (BRCA2) is employed in homologous recombinational repair of DNA damages during meiosis. A common single-nucleotide polymorphism of BRCA2 is associated with severe oligospermia.

Men with mild oligospermia (semen concentration of 15 million to 20 million sperm/ml) were studied for an association of sperm DNA damage with life style factors. A significant association was found between sperm DNA damage and factors such as age, obesity and occupational stress.

In most full-term infant boys with cryptorchidism but no other genital abnormalities, a cause cannot be found, making this a common, sporadic, unexplained (idiopathic) birth defect. A combination of genetics, maternal health, and other environmental factors may disrupt the hormones and physical changes that influence the development of the testicles.

- Severely premature infants can be born before descent of testes. Low birth weight is also a known factor.

- A contributing role of environmental chemicals called endocrine disruptors that interfere with normal fetal hormone balance has been proposed. The Mayo Clinic lists "parents' exposure to some pesticides" as a known risk factor.

- Diabetes and obesity in the mother.

- Risk factors may include exposure to regular alcohol consumption during pregnancy (5 or more drinks per week, associated with a 3x increase in cryptorchidism, when compared to non-drinking mothers. Cigarette smoking is also a known risk factor.

- Family history of undescended testicle or other problems of genital development.

- Cryptorchidism occurs at a much higher rate in a large number of congenital malformation syndromes. Among the more common are Down syndrome Prader–Willi syndrome, and Noonan syndrome.

- In vitro fertilization, use of cosmetics by the mother, and preeclampsia have also been recognized as risk factors for development of cryptorchidism.

In 2008 a study was published that investigated the possible relationship between cryptorchidism and prenatal exposure to a chemical called phthalate (DEHP) which is used in the manufacture of plastics. The researchers found a significant association between higher levels of DEHP metabolites in the pregnant mothers and several sex-related changes, including incomplete descent of the testes in their sons. According to the lead author of the study, a national survey found that 25% of U.S. women had phthalate levels similar to the levels that were found to be associated with sexual abnormalities.

A 2010 study published in the European medical journal "Human Reproduction" examined the prevalence of congenital cryptorchidism among offspring whose mothers had taken mild analgesics, primarily over-the-counter pain medications including ibuprofen (e.g. Advil) and paracetamol (acetaminophen). Combining the results from a survey of pregnant women prior to their due date in correlation with the health of their children and an "ex vivo" rat model, the study found that pregnant women who had been exposed to mild analgesics had a higher prevalence of baby boys born with congenital cryptorchidism.

New insight into the testicular descent mechanism has been hypothesized by the concept of a male programming window (MPW) derived from animal studies. According to this concept, testicular descent status is "set" during the period from 8 to 14 weeks of gestation in humans. Undescended testis is a result of disruption in androgen levels only during this programming window.

In about 30% of infertile men no causative factor is found for their decrease in sperm concentration or quality by common clinical, instrumental, or laboratory means, and the condition is termed "idiopathic" (unexplained). A number of factors may be involved in the genesis of this condition, including age, infectious agents ( such as "Chlamydia trachomatis"), Y chromosome microdeletions, mitochondrial changes, environmental pollutants, and "subtle" hormonal changes.

A review in 2013 came to the result that oligospermia and azoospermia are significantly associated with being overweight (odds ratio 1.1), obese (odds ratio 1.3) and morbidly obese (odds ratio 2.0), but the cause of this is unknown. It found no significant relation between oligospermia and being underweight.

Idiopathic azoospermia is where there is no known cause of the condition. It may be a result of multiple risk factors, such as age and weight. For example, a review in 2013 came to the result that oligospermia and azoospermia are significantly associated with being overweight (odds ratio 1.1), obese (odds ratio 1.3) and morbidly obese (odds ratio 2.0), but the cause of this is unknown. The review found no significant relation between oligospermia and being underweight.

Most cases of polyorchidism are asymptomatic, and are discovered incidentally, in the course of treating another condition. In the majority of cases, the supernumerary testicle is found in the scrotum.

However, polyorchidism can occur in conjunction with cryptorchidism, where the supernumerary testicle is undescended or found elsewhere in the body. These cases are associated with a significant increase in the incidence of testicular cancer: 0.004% for the general population vs 5.7% for a supernumerary testicle not found in the scrotum.

Polyorchidism can also occur in conjunction with infertility, inguinal hernia, testicular torsion, epididymitis, hydrocele testis and varicocele. However, it is not clear whether polyorchidism causes or aggravates these conditions, or whether the existence of these conditions leads sufferers to seek medical attention and thus become diagnosed with a previously undetected supernumerary testicle.

Because polyorchidism is very uncommon, there is no standard treatment for the condition. Prior to advances in ultrasound technology, it was common practice to remove the supernumerary testicle. Several cases have been described where routine follow-up examinations conducted over a period of years showed that the supernumerary testicle was stable.

A meta-analysis in 2009 suggested removing non-scrotal supernumerary testicles because of the increased risk of cancer, and regular follow-up in the remaining cases to ensure that the supernumerary testicle remains stable.

In posttesticular azoospermia sperm are produced but not ejaculated, a condition that affects 7–51% of azoospermic men. The main cause is a physical obstruction (obstructive azoospermia) of the posttesticular genital tracts. The most common reason is a vasectomy done to induce contraceptive sterility. Other obstructions can be congenital (example agenesis of the vas deferens as seen in certain cases of cystic fibrosis) or acquired, such as ejaculatory duct obstruction for instance by infection.

Ejaculatory disorders include retrograde ejaculation and anejaculation; in these conditions sperm are produced but not expelled.

In horses, cryptorchidism is sufficiently common that affected males (ridglings) are routinely gelded.

Rarely, cryptorchidism is due to the presence of a congenital testicular tumor such as a teratoma, which has a tendency to grow large.

To some extent, it is possible to change testicular size. Short of direct injury or subjecting them to adverse conditions, e.g., higher temperature than they are normally accustomed to, they can be shrunk by competing against their intrinsic hormonal function through the use of externally administered steroidal hormones. Steroids taken for muscle enhancement (especially anabolic steroids) often have the undesired side effect of testicular shrinkage.

Similarly, stimulation of testicular functions via gonadotropic-like hormones may enlarge their size. Testes may shrink or atrophy during hormone replacement therapy or through chemical castration.

In all cases, the loss in testes volume corresponds with a loss of spermatogenesis.

It is also known that disruption of the endocrine system by certain chemicals adversely affects the development of the reproductive system and can cause vaginal cancer. Many other reproductive diseases have also been link to exposure to synthetic and environmental chemicals. Common chemicals with known links to reproductive disorders include: lead, dioxins and dioxin-like compounds, styrene, toluene, BPA (Bisphenol A) and pesticides.

Testicular size as a proportion of body weight varies widely. In the mammalian kingdom, there is a tendency for testicular size to correspond with multiple mates (e.g., harems, polygamy). Production of testicular output sperm and spermatic fluid is also larger in polygamous animals, possibly a spermatogenic competition for survival. The testes of the right whale are likely to be the largest of any animal, each weighing around 500 kg (1,100 lb).

Among the Hominidae, gorillas have little female promiscuity and sperm competition and the testes are small compared to body weight (0.03%). Chimpanzees have high promiscuity and large testes compared to body weight (0.3%). Human testicular size falls between these extremes (0.08%).

Testis weight also varies in seasonal breeders like deer and horses. The change is related to changes in testosterone production.

Human testicles are smaller than chimpanzee testicles but larger than gorilla testicles.

Examples of congenital abnormalities of the reproductive system include:

- Kallmann syndrome - Genetic disorder causing decreased functioning of the sex hormone-producing glands caused by a deficiency or both testes from the scrotum.

- Androgen insensitivity syndrome - A genetic disorder causing people who are genetically male (i.e. XY chromosome pair) to develop sexually as a female due to an inability to utilize androgen.

- Intersexuality - A person who has genitalia and/or other sexual traits which are not clearly male or female.

Approximately 1 in 20,000 individuals with a male appearance have 46,XX testicular disorder.

It is a rare condition, with only approximately 60 cases reported as of 1989, and 75 cases as of 2005. However, due to the stigma of intersex conditions and the issues of keeping accurate statistics and records among doctors, it is likely there are more cases than reported.

PMDS type I results from mutations of the gene ("AMH") for AMH on chromosome 19p3.3.

PMDS type II results from mutations of the gene ("AMH-RII") for the AMH receptor on 12q13.

Both types of disorders are inherited as autosomal recessive conditions with expression usually limited to XY offspring.

Treatment includes androgen (testosterone) supplementation to artificially initiate puberty, testicular prosthetic implantation, and psychological support. Gender Dysphoria may result in anorchic individuals who are assigned male at birth and raised as male despite lacking the necessary masculinizing hormones during prenatal, childhood, and adolescent development. Anorchic individuals who have a female identity may be administered estrogen alone in place of testosterone as no androgen blockers are necessary due to the lack of gonads.

In an embryo, the conversion of the gonads into testicles in males-to-be and into ovaries in females-to-be is the function of Leydig cells. In testicular agenesis, this process fails. Penile agenesis can be caused by testicular agenesis. Testes are the sole producer of 5-alpha dihydrotestosterone (5aDHT) in the male body. Where the gonads fail to metamorphose into testes, there is no 5aDHT. Therefore, the masculising process that builds the genital tubercle, the precursor to the penis, is stillborn. When this happens, the child is born with both penile and testicular agenesis and is known by the slang term "nullo". This combination of both conditions is estimated to occur in between 20-30 million male births.

Penile agenesis can exist independently after full testicular development; in this case its cause is unknown.

A problem for people with penile agenesis is the absence of a urinary outlet. Before genital metamorphosis, the urethra runs down the anal wall, to be pulled away by the genital tubercle during male development. Without male development this does not occur. The urethra can be surgically redirected to the rim of the anus immediately after birth to enable urination and avoid consequent internal irritation from urea concentrate. In such cases, the perineum may be left devoid of any genitalia, male or female.

A working penis transplant on to an agenetic patient has never been successful. Only one major penis graft was successfully completed. This occurred in China and the patient shortly rejected it on psychological grounds. However a full female or agenetic to male transplant is not yet facilitated to fulfil full reproductive functions.

On March 18, 2013, it was announced that Andrew Wardle, a British man born without a penis, was going to receive a pioneering surgery to create a penis for him. The surgeons hope to "fold a large flap of skin from his arm — complete with its blood vessels and nerves — into a tube to graft onto his pubic area." If the surgery goes well, the odds of starting a family are very good.

At puberty, most affected individuals require treatment with the male sex hormone testosterone to induce development of male secondary sex characteristics such as facial hair and deepening of the voice (masculinization). Hormone treatment can also help prevent breast enlargement (gynecomastia). Adults with this disorder are usually shorter than average for males and are unable to have children (infertile).

Surgery (orchiopexy) to retrieve the testes and position them in the scrotum is the primary treatment. Occasionally they are unsalvageable if located high in the retroperitoneum. During this surgery, the uterus is usually removed and attempts made to dissect away Müllerian tissue from the vas deferens and epididymis to improve the chance of fertility. If the person has male gender identity himself and the testes cannot be retrieved, testosterone replacement will be usually necessary at puberty should the affected individual choose to pursue medical attention. Lately, laparoscopic hysterectomy is offered to patients as a solution to both improve the chances of fertility and to prevent the occurrences of neoplastic tissue formation.

Sertoli cell only syndrome is like other non-obstructive azoospermia (NOA) cases are managed by sperm retrieval through testicular sperm extraction (mTESE), micro-surgical testicular sperm extraction (mTESE), or testicular biopsy. On retrieval of viable sperm this could be used in Intracytoplasmic Sperm injection ICSI

In 1979, Levin described germinal cell aplasia with focal spermatogenesis where a variable percentage of seminiferous tubules contain germ cells. It is important to discriminate between both in view of ICSI.

A retrospective analysis performed in 2015 detailed the outcomes of N=148 men with non-obstructive azoospermia and diagnosed Sertoli cell-only syndrome:

- Men with SCOS: 148

- Testicular sperm was successfully retrieved: 35/148

- Successful ICSI: 20/148

- Clinical pregnancy: 4/148

This study considers the effect of FSH levels on clinical success, and it excludes abnormal karyotypes. All patients underwent MD-TESE in Iran. Ethnicity and genetic lineage may have an impact on treatment of azoospermia [citation needed].