Torsion is due to a mechanical twisting process. It is also believed that torsion occurring during fetal development can lead to so-called neonatal torsion or vanishing testis, and is one of the causes of an infant being born with monorchism (one testicle).

Torsion is most frequent among adolescents with about 65% of cases presenting between 12–18 years of age. It occurs in about 1 in 4,000 to 1 per 25,000 males per year before 25 years of age; but it can occur at any age, including infancy.

Around 15% of all adult males, up to 35% of men who are evaluated for male infertility, and around 80% of men who are infertile due to some other cause, have varicocele.

Ovarian torsion accounts for about 3% of gynecologic emergencies. The incidence of ovarian torsion among women of all ages is 5.9 per 100,000 women, and the incidence among women of reproductive age (15–45 years) is 9.9 per 100,000 women. In 70% of cases, it is diagnosed in women between 20 and 39 years of age. The risk is greater during pregnancy and in menopause. Risk factors include increased length of the ovarian ligaments, pathologically enlarged ovaries (more than 6 cm), ovarian masses or cysts, and enlarged corpus luteum in pregnancy.

Most cases of polyorchidism are asymptomatic, and are discovered incidentally, in the course of treating another condition. In the majority of cases, the supernumerary testicle is found in the scrotum.

However, polyorchidism can occur in conjunction with cryptorchidism, where the supernumerary testicle is undescended or found elsewhere in the body. These cases are associated with a significant increase in the incidence of testicular cancer: 0.004% for the general population vs 5.7% for a supernumerary testicle not found in the scrotum.

Polyorchidism can also occur in conjunction with infertility, inguinal hernia, testicular torsion, epididymitis, hydrocele testis and varicocele. However, it is not clear whether polyorchidism causes or aggravates these conditions, or whether the existence of these conditions leads sufferers to seek medical attention and thus become diagnosed with a previously undetected supernumerary testicle.

In most full-term infant boys with cryptorchidism but no other genital abnormalities, a cause cannot be found, making this a common, sporadic, unexplained (idiopathic) birth defect. A combination of genetics, maternal health, and other environmental factors may disrupt the hormones and physical changes that influence the development of the testicles.

- Severely premature infants can be born before descent of testes. Low birth weight is also a known factor.

- A contributing role of environmental chemicals called endocrine disruptors that interfere with normal fetal hormone balance has been proposed. The Mayo Clinic lists "parents' exposure to some pesticides" as a known risk factor.

- Diabetes and obesity in the mother.

- Risk factors may include exposure to regular alcohol consumption during pregnancy (5 or more drinks per week, associated with a 3x increase in cryptorchidism, when compared to non-drinking mothers. Cigarette smoking is also a known risk factor.

- Family history of undescended testicle or other problems of genital development.

- Cryptorchidism occurs at a much higher rate in a large number of congenital malformation syndromes. Among the more common are Down syndrome Prader–Willi syndrome, and Noonan syndrome.

- In vitro fertilization, use of cosmetics by the mother, and preeclampsia have also been recognized as risk factors for development of cryptorchidism.

In 2008 a study was published that investigated the possible relationship between cryptorchidism and prenatal exposure to a chemical called phthalate (DEHP) which is used in the manufacture of plastics. The researchers found a significant association between higher levels of DEHP metabolites in the pregnant mothers and several sex-related changes, including incomplete descent of the testes in their sons. According to the lead author of the study, a national survey found that 25% of U.S. women had phthalate levels similar to the levels that were found to be associated with sexual abnormalities.

A 2010 study published in the European medical journal "Human Reproduction" examined the prevalence of congenital cryptorchidism among offspring whose mothers had taken mild analgesics, primarily over-the-counter pain medications including ibuprofen (e.g. Advil) and paracetamol (acetaminophen). Combining the results from a survey of pregnant women prior to their due date in correlation with the health of their children and an "ex vivo" rat model, the study found that pregnant women who had been exposed to mild analgesics had a higher prevalence of baby boys born with congenital cryptorchidism.

New insight into the testicular descent mechanism has been hypothesized by the concept of a male programming window (MPW) derived from animal studies. According to this concept, testicular descent status is "set" during the period from 8 to 14 weeks of gestation in humans. Undescended testis is a result of disruption in androgen levels only during this programming window.

Often the greatest concern with respect to varicocele is its effect on male fertility. The relationship between varicocele and infertility is unclear; some men with the condition are fertile, some have sperm that are normal in shape and move normally, but are compromised in function, and some have sperm with abnormal shapes or that do not move well. Theories as to how variocele affects sperm function include damage via excess heat caused by the blood pooling and oxidative stress on sperm (ROS).

Tobacco smoking and mutations in the gene expressing glutathione S-transferase Mu 1 both put men at risk for infertility; these factors may also exacerbate the risk that varicocele will affect fertility.

A hydrocele testis is not generally thought to affect fertility. However, it may be indicative of other factors that may affect fertility.

Because polyorchidism is very uncommon, there is no standard treatment for the condition. Prior to advances in ultrasound technology, it was common practice to remove the supernumerary testicle. Several cases have been described where routine follow-up examinations conducted over a period of years showed that the supernumerary testicle was stable.

A meta-analysis in 2009 suggested removing non-scrotal supernumerary testicles because of the increased risk of cancer, and regular follow-up in the remaining cases to ensure that the supernumerary testicle remains stable.

This can be due to:

- One testicle not descending into the scrotum during normal embryonic or fetal development (3–4% of 'normal' live births), also known as undescended testis or cryptorchidism. In this case the testis is within the abdominal cavity, somewhere along the normal route of descent – most commonly, within the inguinal canal. Such a testis has an increased risk of malignancy.

- One testicle may disappear during development (the so-called vanishing testis) due to some intrauterine insult. This is thought to be most likely vascular, such as testicular torsion.

- One testicle may have been surgically removed through orchiectomy.

- One testicle may be injured.

An individual having monorchism can be referred to as "monorchid".

One of the strongest arguments for early orchiopexy is reducing the risk of testicular cancer. About 1 in 500 men born with one or both testes undescended develops testicular cancer, roughly a 4 to 40 fold increased risk. The peak incidence occurs in the 3rd and 4th decades of life. The risk is higher for intra-abdominal testes and somewhat lower for inguinal testes, but even the "normally descended" testis of a man whose other testis was undescended has about a 20% higher cancer risk than those of other men.

The most common type of testicular cancer occurring in undescended testes is seminoma. It is usually treatable if caught early, so urologists often recommend that boys who had orchiopexy as infants be taught testicular self-examination, to recognize testicular masses and seek early medical care for them. Cancer developing in an intra-abdominal testis would be unlikely to be recognized before considerable growth and spread, and one of the advantages of orchiopexy is that a mass developing in a scrotal testis is far easier to recognize than an intra-abdominal mass.

It was originally felt that orchidopexy resulted in easier detection of testis cancer but did not lower the risk of actually developing cancer. However, recent data has resulted in a paradigm shift. The New England Journal of Medicine published in 2007 that orchidopexy performed before puberty resulted in a significantly reduced risk of testicular cancer than if done after puberty.

The risk of malignancy in the undescended testis is 4 to 10 times higher than that in the general population and is approximately 1 in 80 with a unilateral undescended testis and 1 in 40 to 1 in 50 for bilateral undescended testes. The peak age for this tumor is 15–45 yr. The most common tumor developing in an undescended testis is a seminoma (65%); in contrast, after orchiopexy, seminomas represent only 30% of testis tumors.

A hydrocele testis is an accumulation of clear fluid in the tunica vaginalis, the most internal of membranes containing a testicle. A primary hydrocele causes a painless enlargement in the scrotum on the affected side and is thought to be due to the defective absorption of fluid secreted between the two layers of the tunica vaginalis (investing membrane). A secondary hydrocele is secondary to either inflammation or a neoplasm in the testis.

A hydrocele usually occurs on one side, but can also affect both sides. The accumulation can be a marker of physical trauma, infection, tumor or varicocele surgery, but the cause is generally unknown. Indirect inguinal hernia indicates increased risk of hydrocele.

A hydrocele is normally seen in infant boys, as an enlarged scrotum. In infant girls, it appears as enlarged labia. However, hydroceles are more common in boys than girls.

The development of an ovarian mass is related to the development of torsion. In the reproductive years, regular growth of large corpus luteal cysts are a risk factor for rotation. The mass effect of ovarian tumors is also a common cause of torsion. Torsion of the ovary usually occurs with torsion of the fallopian tube as well on their shared vascular pedicle around the broad ligament, although in rare cases the ovary rotates around the mesovarium or the fallopian tube rotates around the mesosalpinx. In 80%, torsion happens unilaterally, with slight predominance on the right.

Fournier's gangrene ( an aggressive and rapidly spreading infection of the perineum ) usually presents with fever and intense pain. It is a rare condition but fatal if not identified and aggressively treated with a combination of surgical debridement and broad spectrum antibiotics.

Orchitis is not rare in bulls and rams.

It has also been described in roosters.

Ultrasound is useful if the cause is not certain based on the above measures. If the diagnosis of torsion is certain, imaging should not delay definitive management such as physical maneuvers and surgery.

There is increasing evidence that the harmful products of tobacco smoking may damage the testicles and kill sperm, but their effect on male fertility is not clear. Some governments require manufacturers to put warnings on packets. Smoking tobacco increases intake of cadmium, because the tobacco plant absorbs the metal. Cadmium, being chemically similar to zinc, may replace zinc in the DNA polymerase, which plays a critical role in sperm production. Zinc replaced by cadmium in DNA polymerase can be particularly damaging to the testes.

Pre-testicular factors refer to conditions that impede adequate support of the testes and include situations of poor hormonal support and poor general health including:

- Hypogonadotropic hypogonadism due to various causes

- Obesity increases the risk of hypogonadotropic hypogonadism. Animal models indicate that obesity causes leptin insensitivity in the hypothalamus, leading to decreased Kiss1 expression, which, in turn, alters the release of gonadotropin-releasing hormone (GnRH).

- Undiagnosed and untreated coeliac disease (CD). Coeliac men may have reversible infertility. Nevertheless, CD can present with several non-gastrointestinal symptoms that can involve nearly any organ system, even in the absence of gastrointestinal symptoms. Thus, the diagnosis may be missed, leading to a risk of long-term complications. In men, CD can reduce semen quality and cause immature secondary sex characteristics, hypogonadism and hyperprolactinaemia, which causes impotence and loss of libido. The giving of gluten free diet and correction of deficient dietary elements can lead to a return of fertility. It is likely that an effective evaluation for infertility would best include assessment for underlying celiac disease, both in men and women.

- Drugs, alcohol

- Strenuous riding (bicycle riding, horseback riding)

- Medications, including those that affect spermatogenesis such as chemotherapy, anabolic steroids, cimetidine, spironolactone; those that decrease FSH levels such as phenytoin; those that decrease sperm motility such as sulfasalazine and nitrofurantoin

- Genetic abnormalities such as a Robertsonian translocation

Testicular size as a proportion of body weight varies widely. In the mammalian kingdom, there is a tendency for testicular size to correspond with multiple mates (e.g., harems, polygamy). Production of testicular output sperm and spermatic fluid is also larger in polygamous animals, possibly a spermatogenic competition for survival. The testes of the right whale are likely to be the largest of any animal, each weighing around 500 kg (1,100 lb).

Among the Hominidae, gorillas have little female promiscuity and sperm competition and the testes are small compared to body weight (0.03%). Chimpanzees have high promiscuity and large testes compared to body weight (0.3%). Human testicular size falls between these extremes (0.08%).

Testis weight also varies in seasonal breeders like deer and horses. The change is related to changes in testosterone production.

Human testicles are smaller than chimpanzee testicles but larger than gorilla testicles.

To some extent, it is possible to change testicular size. Short of direct injury or subjecting them to adverse conditions, e.g., higher temperature than they are normally accustomed to, they can be shrunk by competing against their intrinsic hormonal function through the use of externally administered steroidal hormones. Steroids taken for muscle enhancement (especially anabolic steroids) often have the undesired side effect of testicular shrinkage.

Similarly, stimulation of testicular functions via gonadotropic-like hormones may enlarge their size. Testes may shrink or atrophy during hormone replacement therapy or through chemical castration.

In all cases, the loss in testes volume corresponds with a loss of spermatogenesis.

In most cases where orchitis is caused by epididymitis, treatment is an oral antibiotic such as cefalexin or ciprofloxacin until infection clears up. In both causes non-steroidal anti-inflammatory drugs such as naproxen or ibuprofen are recommended to relieve pain. Sometimes stronger pain medications in the opiate category are called for and are frequently prescribed by experienced emergency room physicians.

PMDS type I results from mutations of the gene ("AMH") for AMH on chromosome 19p3.3.

PMDS type II results from mutations of the gene ("AMH-RII") for the AMH receptor on 12q13.

Both types of disorders are inherited as autosomal recessive conditions with expression usually limited to XY offspring.

Because both the Wolffian ducts and Müllerian ducts begin to develop, the tissues are often intertwined, resulting in obstruction or nonpatency of the vas deferens or other parts of the reproductive excretory ducts. This can result in infertility, the most serious potential problem caused by this condition. Sometimes, transverse testicular ectopia is evident.

Cryptorchidism in AMH deficiency suggests that AMH may play a role in transabdominal testicular descent, perhaps by facilitating contraction of the gubernaculum.

Other Müllerian derivatives which may be present in at least a rudimentary form are the cervix, upper part of the vagina, and fallopian tubes.

The condition can come to attention because of a bulge in the inguinal canal of an XY infant due to herniation of the uterus. The presence of a uterus may be noticed if an ultrasound or MRI of the pelvis is performed to locate the testes or for other reasons. Occasionally the uterus is discovered during abdominal surgery for some other purpose in later childhood or adult life.

Although persistent Müllerian duct syndrome is classified as an intersex condition, it does not involve ambiguity or malformation of the external genitalia, which appear typical (apart from cryptorchidism if present). Sometimes the uterus enters a hernia. Sometimes the Müllerian structures get entangled with the spermatic ducts and interfere with the descent of the testes.

Apart from humans, this syndrome has been reported in dogs.

Secondary hydroceles due to testicular diseases can be the result of cancer, trauma (such as a hernia), or orchitis (inflammation of testis), and can also occur in infants undergoing peritoneal dialysis. A hydrocele is not a cancer but it should be excluded clinically if a presence of a testicular tumor is suspected, however, there are no publications in the world literature that report a hydrocele in association with testicular cancer. Secondary hydrocele is most frequently associated with acute or chronic epididymo-orchitis. It is also seen with torsion of the testis and with some testicular tumors. A secondary hydrocele is usually lax and of moderate size: the underlying testis is palpable. A secondary hydrocele subsides when the primary lesion resolves.

- Acute/chronic epididymo-orchitis

- Torsion of testis

- Testicular tumor

- Hematocele

- Filarial hydrocele

- Post herniorrhaphy

- Hydrocele of an hernial sac