Links between maternal smoking and TDS are tenuous, but there are stronger associations between maternal alcohol consumption and incidences of cryptorchidism in sons. Smoking does however affect the growth of a fetus, and low birth weight is shown to increase the likelihood of all the disorders encompassed by TDS. Maternal obesity, resulting in gestational diabetes, has also been shown to be a risk factor for impaired testes development and TDS symptoms in sons.

Exposure of a male fetus to substances that disrupt hormone systems, particularly chemicals that inhibit the action of androgens (male sex hormones) during the development of the reproductive system, has been shown to cause many of the characteristic TDS disorders. These include environmental estrogens and anti-androgens found in food and water sources that have been contaminated with synthetic hormones and pesticides used in agriculture. In historical cases, medicines given to pregnant women, like diethylstilbestrol (DES), have caused many of the features of TDS in fetuses exposed to this chemical during gestation. The impact of environmental chemicals is well documented in animal models. If a substance affects Sertoli and Leydig cell differentiation (a common feature of TDS disorders) at an early developmental stage, germ cell growth and testosterone production will be impaired. These processes are essential for testes descent and genitalia development, meaning that genital abnormalities like cryptorchidism or hypospadias may be present from birth, and fertility problems and TGCC become apparent during adult life. Severity or number of disorders may therefore be dependent on the timing of the environmental exposure. Environmental factors can act directly, or via epigenetic mechanisms, and it is likely that a genetic susceptibility augmented by environmental factors is the primary cause of TDS.

There is increasing evidence that the harmful products of tobacco smoking may damage the testicles and kill sperm, but their effect on male fertility is not clear. Some governments require manufacturers to put warnings on packets. Smoking tobacco increases intake of cadmium, because the tobacco plant absorbs the metal. Cadmium, being chemically similar to zinc, may replace zinc in the DNA polymerase, which plays a critical role in sperm production. Zinc replaced by cadmium in DNA polymerase can be particularly damaging to the testes.

Pre-testicular factors refer to conditions that impede adequate support of the testes and include situations of poor hormonal support and poor general health including:

- Hypogonadotropic hypogonadism due to various causes

- Obesity increases the risk of hypogonadotropic hypogonadism. Animal models indicate that obesity causes leptin insensitivity in the hypothalamus, leading to decreased Kiss1 expression, which, in turn, alters the release of gonadotropin-releasing hormone (GnRH).

- Undiagnosed and untreated coeliac disease (CD). Coeliac men may have reversible infertility. Nevertheless, CD can present with several non-gastrointestinal symptoms that can involve nearly any organ system, even in the absence of gastrointestinal symptoms. Thus, the diagnosis may be missed, leading to a risk of long-term complications. In men, CD can reduce semen quality and cause immature secondary sex characteristics, hypogonadism and hyperprolactinaemia, which causes impotence and loss of libido. The giving of gluten free diet and correction of deficient dietary elements can lead to a return of fertility. It is likely that an effective evaluation for infertility would best include assessment for underlying celiac disease, both in men and women.

- Drugs, alcohol

- Strenuous riding (bicycle riding, horseback riding)

- Medications, including those that affect spermatogenesis such as chemotherapy, anabolic steroids, cimetidine, spironolactone; those that decrease FSH levels such as phenytoin; those that decrease sperm motility such as sulfasalazine and nitrofurantoin

- Genetic abnormalities such as a Robertsonian translocation

It is a rare condition, with only approximately 60 cases reported as of 1989, and 75 cases as of 2005. However, due to the stigma of intersex conditions and the issues of keeping accurate statistics and records among doctors, it is likely there are more cases than reported.

Idiopathic azoospermia is where there is no known cause of the condition. It may be a result of multiple risk factors, such as age and weight. For example, a review in 2013 came to the result that oligospermia and azoospermia are significantly associated with being overweight (odds ratio 1.1), obese (odds ratio 1.3) and morbidly obese (odds ratio 2.0), but the cause of this is unknown. The review found no significant relation between oligospermia and being underweight.

In an embryo, the conversion of the gonads into testicles in males-to-be and into ovaries in females-to-be is the function of Leydig cells. In testicular agenesis, this process fails. Penile agenesis can be caused by testicular agenesis. Testes are the sole producer of 5-alpha dihydrotestosterone (5aDHT) in the male body. Where the gonads fail to metamorphose into testes, there is no 5aDHT. Therefore, the masculising process that builds the genital tubercle, the precursor to the penis, is stillborn. When this happens, the child is born with both penile and testicular agenesis and is known by the slang term "nullo". This combination of both conditions is estimated to occur in between 20-30 million male births.

Penile agenesis can exist independently after full testicular development; in this case its cause is unknown.

A problem for people with penile agenesis is the absence of a urinary outlet. Before genital metamorphosis, the urethra runs down the anal wall, to be pulled away by the genital tubercle during male development. Without male development this does not occur. The urethra can be surgically redirected to the rim of the anus immediately after birth to enable urination and avoid consequent internal irritation from urea concentrate. In such cases, the perineum may be left devoid of any genitalia, male or female.

A working penis transplant on to an agenetic patient has never been successful. Only one major penis graft was successfully completed. This occurred in China and the patient shortly rejected it on psychological grounds. However a full female or agenetic to male transplant is not yet facilitated to fulfil full reproductive functions.

On March 18, 2013, it was announced that Andrew Wardle, a British man born without a penis, was going to receive a pioneering surgery to create a penis for him. The surgeons hope to "fold a large flap of skin from his arm — complete with its blood vessels and nerves — into a tube to graft onto his pubic area." If the surgery goes well, the odds of starting a family are very good.

The prevalence remains sparsely investigated. To date, two population-based nationwide studies have been conducted both estimating a prevalence about 1 in 5000 live female births. According to some reports, Queen Amalia of Greece may have had the syndrome, but a 2011 review of the historical evidence concludes that it is not possible to determine the inability of her and her husband to have a child. Her inability to provide an heir contributed to the overthrow of her husband, King Otto.

In posttesticular azoospermia sperm are produced but not ejaculated, a condition that affects 7–51% of azoospermic men. The main cause is a physical obstruction (obstructive azoospermia) of the posttesticular genital tracts. The most common reason is a vasectomy done to induce contraceptive sterility. Other obstructions can be congenital (example agenesis of the vas deferens as seen in certain cases of cystic fibrosis) or acquired, such as ejaculatory duct obstruction for instance by infection.

Ejaculatory disorders include retrograde ejaculation and anejaculation; in these conditions sperm are produced but not expelled.

Individuals with CAVD can reproduce with the assistance of modern technology with a combination of testicular sperm extraction and intracytoplasmic sperm injection (ICSI). However, as the risk of either cystic fibrosis or renal agenesis is likely to be higher in the children, genetic counseling is generally recommended.

Congenital anomalies like cryptorchidism, renal agenesis/dysplasia, musculoskeletal and cardiopulmonary anomalies are also common (>50% cases), hence evaluation of the patient for internal anomalies is mandatory.

Although aphallia can occur in any body type, it is considered a substantially more troublesome problem with those who have testes present, and has in the past sometimes been considered justification for assigning and rearing a genetically male infant as a girl. After the theory in the 1950s that gender as a social construct was purely nurture and so an individual child could be raised early on and into one gender or the other regardless of their genetics or brain chemistry. Intersex people generally advocate harshly against coercive genital reassignment however, and encourage infants to be raised choosing their own gender identity. The nurture theory has been largely abandoned and cases of trying to rear children this way have not proven to be successful transitions.

In newborn period or infancy, feminizing operations are recommended for treatment of penile agenesis, but after 2 years, as sexual identification of the patients has appeared, it is advised to perform masculinizing operations in order not to disturb the child psychologically.

Recent advances in surgical phalloplasty techniques have provided additional options for those still interested in pursuing surgery.

WNT4 (found on the short arm (p) of chromosome 1) has been clearly implicated in the atypical version of this disorder. A genetic mutation causes a leucine to proline residue substitution at amino acid position 12. This occurrence reduces the intranuclear levels of β catenin. In addition, it removes the inhibition of steroidogenic enzymes like 3β-hydroxysteriod dehydrogenase and 17α-hydroxylase. Patients therefore have androgen excess. Furthermore, without WNT4, the Müllerian duct is either deformed or absent. Female reproductive organs, such as the cervix, fallopian tubes, ovaries, and much of the vagina, are hence affected.

An association with a deletion mutation in the long arm (q) of chromosome 17 (17q12) has been reported. The gene LHX1 is located in this region and may be the cause of a number of these cases.

Growth of the penis both before birth and during childhood and puberty is strongly influenced by testosterone and, to a lesser degree, the growth hormone. However, later endogenous hormones mainly have value in the treatment of micropenis caused by hormone deficiencies, such as hypopituitarism or hypogonadism.

Regardless of the cause of micropenis, if it is recognized in infancy, a brief course of testosterone is often prescribed (usually no more than 3 months). This usually induces a small amount of growth, confirming the likelihood of further growth at puberty, but rarely achieves normal size. No additional testosterone is given during childhood, to avoid unwanted virilization and bone maturation. (There is also some evidence that premature administration of testosterone can lead to reduced penis size in the adult.)

Testosterone treatment is resumed in adolescence only for boys with hypogonadism. Penile growth is completed at the end of puberty, similar to the completion of height growth, and provision of extra testosterone to post-pubertal adults produces little or no further growth.

Of the abnormal conditions associated with micropenis, most are conditions of reduced prenatal androgen production or effect, such as abnormal testicular development (testicular dysgenesis), Klinefelter syndrome, Leydig cell hypoplasia), specific defects of testosterone or dihydrotestosterone synthesis (17,20-lyase deficiency, 5α-reductase deficiency), androgen insensitivity syndromes, inadequate pituitary stimulation (gonadotropin deficiency), and other forms of congenital hypogonadism. Micropenis can also occur as part of many genetic malformation syndromes that do not involve the sex chromosomes. It is sometimes a sign of congenital growth-hormone deficiency or congenital hypopituitarism. Several homeobox genes affect penis and digit size without detectable hormone abnormalities.

In addition, in utero exposure to some estrogen based fertility drugs like diethylstilbestrol (DES) has been linked to genital abnormalities and/or a smaller than normal penis.

After evaluation to detect any of the conditions described above, micropenis can often be treated in infancy with injections of various hormones, such as human chorionic gonadotropin and testosterone.

Most eight- to fourteen-year-old boys referred for micropenis do not have the micropenis condition. Such concerns are usually explained by one of the following:

- a penis concealed in suprapubic fat (extra fat around the mons pubis)

- a large body and frame for which a prepubertal penis simply appears too small

- delayed puberty with every reason to expect good future growth

Examples of congenital abnormalities of the reproductive system include:

- Kallmann syndrome - Genetic disorder causing decreased functioning of the sex hormone-producing glands caused by a deficiency or both testes from the scrotum.

- Androgen insensitivity syndrome - A genetic disorder causing people who are genetically male (i.e. XY chromosome pair) to develop sexually as a female due to an inability to utilize androgen.

- Intersexuality - A person who has genitalia and/or other sexual traits which are not clearly male or female.

There are two main populations of CAVD; the larger group is associated with

cystic fibrosis and occurs because of a mutation in the CFTR gene, while the smaller group (estimated between 10 and 40%) is associated with Unilateral Renal agenesis (URA). The genetic basis of this second group is not well understood.

Mutation of the CFTR gene is found to result in obstructive azoospermia in postpubertal males with cystic fibrosis. Strikingly, CAVD is one of the most consistent features of cystic fibrosis as it affects 98-99% of individuals in this CF patient population. In contrast, acute or persistent respiratory symptoms present in only 51% of total CF patients.

In the subset of males with both CBAVD and URA, the CFTR mutation has been shown to occur at a rate only slightly higher than the overall population. Thus, McCallum, et al. have suggested another mutation may be responsible for this condition.

Vaginal hypoplasia is estimated to occur in 1 in 4,000–5,000 live female births. It is often unnoticed until adolescence when pain and a lack of menstrual flow indicates the condition.

Cervical agenesis is estimated to occur in 1 in 80,000 females. It is often associated with deformity of the vagina; one study found that 48% of patients with cervical agenesis had a normal, functional vagina, while the rest of the cases were accompanied by vaginal hypoplasia.

Nuclear receptor subfamily 5 group A member 1 (NR5A1), also known as SF1 or Ad4BP (MIM 184757), is located on the long arm of chromosome 9 (9q33.3). The NR5A1 is an orphan nuclear receptor that was first identified following the search for a common regulator of the cytochrome P450 steroid hydroxylase enzyme family. This receptor is a pivotal transcriptional regulator of an array of genes involved in reproduction, steroidogenesis and male sexual differentiation and also plays a crucial role in adrenal gland formation in both sexes. NR5A1 regulates the mullerian inhibitory substance by binding to a conserved upstream regulatory element and directly participates in the process of mammalian sex determination through mullerian duct regression. Targeted disruption of NR5A1 (Ftzf1) in mice results in gonadal and adrenal agenesis, persistence of Mullerian structures and abnormalities of the hypothalamus and pituitary gonadotropes. Heterozygous animals demonstrate a milder phenotype including an impaired adrenal stress response and reduced testicular size. In humans, NR5A1 mutations were first described in patients with 46, XY karyotype and disorders of sex development (DSD), Mullerian structures and primary adrenal failure (MIM 612965). After that, heterozygous NR5A1 mutations were described in seven patients showing 46, XY karyotype and ambiguous genitalia, gonadal dysgenesis, but no adrenal insufficiency. Since then, studies have confirmed that mutations in NR5A1 in patients with 46, XY karyotype cause severe underandrogenisation, but no adrenal insufficiency, establishing dynamic and dosage-dependent actions for NR5A1. Subsequent studies revealed that NR5A1 heterozygous mutations cause primary ovarian insufficiency (MIM 612964).

It is also known that disruption of the endocrine system by certain chemicals adversely affects the development of the reproductive system and can cause vaginal cancer. Many other reproductive diseases have also been link to exposure to synthetic and environmental chemicals. Common chemicals with known links to reproductive disorders include: lead, dioxins and dioxin-like compounds, styrene, toluene, BPA (Bisphenol A) and pesticides.

Leydig cell hypoplasia (or aplasia) (LCH), also known as Leydig cell agenesis, is a rare autosomal recessive genetic and endocrine syndrome affecting an estimated 1 in 1,000,000 genetic males. It is characterized by an inability of the body to respond to luteinizing hormone (LH), a gonadotropin which is normally responsible for signaling Leydig cells of the testicles to produce testosterone and other androgen sex hormones. The condition manifests itself as pseudohermaphroditism (partially or fully underdeveloped genitalia), hypergonadotropic hypogonadism (decreased or lack of production of sex steroids by the gonads despite high circulating levels of gonadotropins), reduced or absent puberty (lack of development of secondary sexual characteristics, resulting in sexual infantilism if left untreated), and infertility.

Leydig cell hypoplasia does not occur in biological females as they do not have either Leydig cells or testicles. However, the cause of the condition in males, luteinizing hormone insensitivity, does affect females, and because LH plays a role in the female reproductive system, it can result in primary amenorrhea or oligomenorrhea (absent or reduced menstruation), infertility due to anovulation, and ovarian cysts.

A related condition is follicle-stimulating hormone (FSH) insensitivity, which presents with similar symptoms to those of Leydig cell hypoplasia but with the symptoms in the respective sexes reversed (i.e., hypogonadism and sexual infantilism in females and merely problems with fertility in males). Despite their similar causes, FSH insensitivity is considerably less common in comparison to LH insensitivity.

About 10–15% of human couples are infertile, unable to conceive. In approximately in half of these cases, the underlying cause is related to the male. The underlying causative factors in the male infertility can be attributed to environmental toxins, systemic disorders such as, hypothalamic–pituitary disease, testicular cancers and germ-cell aplasia. Genetic factors including aneuploidies and single-gene mutations are also contributed to the male infertility. Patients suffering from nonobstructive azoospermia or oligozoospermia show microdeletions in the long arm of the Y chromosome and/or chromosomal abnormalities, each with the respective frequency of 9.7% and 13%. A large percentage of human male infertility is estimated to be caused by mutations in genes involved in primary or secondary spermatogenesis and sperm quality and function. Single-gene defects are the focus of most research carried out in this field.

NR5A1 mutations are associated with male infertility, suggesting the possibility that these mutations cause the infertility. However, it is possible that these mutations individually have no major effect and only contribute to the male infertility by collaboration with other contributors such as environmental factors and other genomics variants. Vice versa, existence of the other alleles could reduce the phenotypic effects of impaired NR5A1 proteins and attenuate the expression of abnormal phenotypes and manifest male infertility solely.

The prevalence of uterine malformation is estimated to be 6.7% in the general population, slightly higher (7.3%) in the infertility population, and significantly higher in a population of women with a history of recurrent miscarriages (16%).

Patients with Leydig cell hypoplasia may be treated with hormone replacement therapy (i.e., with androgens), which will result in normal sexual development and the resolution of most symptoms. In the case of 46,XY (genetically "male") individuals who are phenotypically female and/or identify as the female gender, estrogens should be given instead. Surgical correction of the genitals in 46,XY males may be required, and, if necessary, an orchidopexy (relocation of the undescended testes to the scrotum) may be performed as well.