Fire breathing is typically performed with a high flash point fuel, such as lamp oil (liquid paraffin), while fire eating is performed with low flash point fuels, such as white gas or naphtha. Highly purified fuels are preferred by fire performers due to their minimized toxicity, but other, more dangerous fuels may sometimes be used, such as ethanol, isopropanol, kerosene, gasoline, or charcoal lighter fluid. All fuels run the risk of causing pneumonitis if inhaled, however longer chain oils are more persistent than smaller molecules. Alcohols and volatile naphthas are likely to be absorbed or expelled from the body by evaporation and respiration.

"Fire-eater's lung" is an important variant of hydrocarbon pneumonitis, which typically involves adolescents or young adults who are exposed through mishap during flame-blowing performances using a variety of different flammable materials. The substances used overlap with some of the pediatric exposures (kerosene, gasoline) but can also include other hydrocarbons such as jet fuel and, in France, an aromatic hydrocarbon enriched petroleum-distillate called "kerdan". There has also been a case of citronella oil aspiration in a fire-eater. As with hydrocarbon pneumonitis in children, fire-eater's lung can also be complicated by pneumatocele. Although the term "acute lipoid pneumonia" has been used to refer to the "fire-eater's lung" syndrome, this is a misnomer.

Fire breather’s pneumonia is caused by the entrance of hydrocarbon fuels into the bronchial tree, usually due to accidental aspiration or inhalation during a fire performance show. Fire breathing, or fire blowing, is the act of creating a plume of fire by blowing a mouthful of fuel in a fine mist (atomization) over a source of ignition. Fire eating, or fire swallowing, is the act of putting a flaming object into the mouth and extinguishing it.

In both disciplines, the performer holds their breath until the air is clear of vapors, so as to not inhale the hazardous fumes. However, improper technique or an accident can lead to ingestion, inhalation, or aspiration of fine droplets or vapors. Fire breathing and fire eating are separate acts, but the terms are sometimes erroneously used interchangeably in the literature.

Fuel ingestion can also occur due to siphoning by mouth of fuel products.

Once inhaled, these fuels induce an inflammatory reaction in lung tissue. They are not metabolized by tissue enzymes, but undergo emulsification and become engulfed by macrophages which, with time, may disintegrate and release oily substances surrounded by fibrous tissue and giant cells.

Sources of such lipids could be either exogenous or endogenous.

Exogenous: from outside the body. For example, inhaled nose drops with an oil base, or accidental inhalation of cosmetic oil. Amiodarone is an anti-arrythmic known to cause this condition. Oil pulling has also been shown to be a cause. At risk populations include the elderly, developmentally delayed or persons with gastroesophageal reflux. Switching to water-soluble alternatives may be helpful in some situations.

Endogenous: from the body itself, for example, when an airway is obstructed, it is often the case that distal to the obstruction, lipid-laden macrophages (foamy macrophages) and giant cells fill the lumen of the disconnected airspace.

Sixty percent of people with acute interstitial pneumonitis will die in the first six months of illness. The median survival is 1½ months.

However, most people who have one episode do not have a second. People who survive often recover lung function completely.

Hydrocarbon pneumonitis is a kind of chemical pneumonitis which occurs with oral ingestion of hydrocarbons and associated aspiration. It occurs prominently among children, accounting for many hospital admissions each year. Common hydrocarbons involved are mineral spirits, mineral seal oil (common in furniture polish), lamp oil, kerosene (paraffin), turpentine (pine oil), gasoline, and lighter fluid. Pneumatocele is a complication of hydrocarbon pneumonitis. In both childhood and adult pneumonitis, hydrocarbon aspiration occurs at the time of initial ingestion event or subsequently with vomiting. Low viscosity of an ingested hydrocarbon is considered a major factor promoting aspiration (presumably for mechanical reasons). Contrary to aspiration hydrocarbon pneumonitis, hydrocarbon (solvent) vapor inhalation manifests primarily in either central nervous system or cardiac effects.

Endogenous lipoid pneumonia and non-specific interstitial pneumonitis has been seen prior to the development of pulmonary alveolar proteinosis in a child.

Chemical pneumonitis is inflammation of the lung caused by aspirating or inhaling irritants. It is sometimes called a "chemical pneumonia", though it is not infectious. There are two general types of chemical pneumonitis: acute and chronic.

Irritants capable of causing chemical pneumonitis include vomitus, barium used in gastro-intestinal imaging, chlorine gas (among other pulmonary agents), ingested gasoline or other petroleum distillates, ingested or skin absorbed pesticides, gases from electroplating, smoke and others. It may also be caused by the use of inhalants.

Mendelson's syndrome is a type of chemical pneumonitis.

Mineral oil should not be given internally to young children, pets, or anyone with a cough, hiatus hernia, or nocturnal reflux, because it can cause complications such as lipoid pneumonia. Due to its low density, it is easily aspirated into the lungs, where it cannot be removed by the body. In children, if aspirated, the oil can work to prevent normal breathing, resulting in death of brain cells and permanent paralysis and/or retardation

The following are precautionary measures that can be taken to avoid the spread of bagassosis:

1. Dust control-prevention /suppression of dust such as wet process, enclosed apparatus, exhaust ventilation etc. should be used

2. Personal protection- masks/ respirators

3. Medical control- initial medical examination & periodical checkups of workers

4. Bagasse control- keep moisture content above 20% and spray bagasse with 2% propionic acid

Pulmonary aspiration of acidic material (such as stomach acid) may produce an immediate primary injury caused by the chemical reaction of acid with lung parenchyma, and a later secondary injury as a result of the subsequent inflammatory response.

Acute interstitial pneumonitis occurs most frequently among people older than forty years old. It affects men and women equally. There are no known risk factors; in particular, smoking is not associated with increased risk.

Flock worker's lung is caused by exposure to small pieces of flock, usually nylon, created during the flocking process and inhaled. Exposure to rotary-cut flock particulates is the main risk factor; whether or not other types of flock cause this pulmonary fibrosis is not yet determined. Other types of flock include rayon, polypropylene, and polyethylene. Workers exposed to nylon, polypropylene, polyethylene, and rayon flocking debris have developed flock worker's lung. Exposure to higher concentrations of respirable flock particles is associated with more severe disease.

Whether or not smoking affects the progression or incidence of flock worker's lung is a topic of ongoing research as of 2015. Research in rats has shown that nylon flocking is a causative agent.

Pulmonary aspiration of particulate matter may result in acute airway obstruction which may rapidly lead to death from arterial hypoxemia.

It can be classified into acute interstitial pneumonitis, blood pneumonitis, lymphocytic interstitial pneumonitis, radiation pneumonitis, and uremic pneumonitis.

FLD affects approximately .5%-3% of farmers. In some regions of the world such as Asia, the infection rate is more around 6%.

Pneumonia is due to infections caused primarily by bacteria or viruses and less commonly by fungi and parasites. Although there are more than 100 strains of infectious agents identified, only a few are responsible for the majority of the cases. Mixed infections with both viruses and bacteria may occur in up to 45% of infections in children and 15% of infections in adults. A causative agent may not be isolated in approximately half of cases despite careful testing.

The term "pneumonia" is sometimes more broadly applied to any condition resulting in inflammation of the lungs (caused for example by autoimmune diseases, chemical burns or drug reactions); however, this inflammation is more accurately referred to as pneumonitis.

Conditions and risk factors that predispose to pneumonia include smoking, immunodeficiency, alcoholism, chronic obstructive pulmonary disease, asthma, chronic kidney disease, and liver disease. The use of acid-suppressing medications—such as proton-pump inhibitors or H2 blockers—is associated with an increased risk of pneumonia. The risk is also increased in old age.

Acute:

- Cough

- Difficulty Breathing

- Abnormal lung sounds (wet, gurgling sounding breaths)

- Chest pain, tightness or burning

Chronic:

- Persistent cough

- Shortness of breath

- Increased susceptibility to respiratory illness

Symptoms of chronic chemical pneumonitis may or may not be present, and can take months or years to develop to the point of noticeability.

Flock worker's lung can be prevented with engineering controls that protect workers from inhaling flock. Engineering controls to prevent inhalation of flock can include using guillotine cutters rather than rotary cutters, and ensuring that blades are sharp, since dull blades shear off more respirable particles. Flocking plants have also implemented medical surveillance programs for workers to diagnose cases at an earlier stage. Another technique for preventing flock worker's lung is cleaning the workplace with alternatives to compressed air in order to avoid resuspending particulates in the air.

Whether aspiration pneumonia represents a true bacterial infection or a chemical inflammatory process remains the subject of significant controversy. Both causes may be present with similar symptoms.

Regardless of cause, UIP is relentlessly progressive, usually leading to respiratory failure and death without a lung transplant. Some patients do well for a prolonged period of time, but then deteriorate rapidly because of a superimposed acute illness (so-called "accelerated UIP"). The outlook for long-term survival is poor. In most studies, the median survival is 3 to 4 years. Patients with UIP in the setting of rheumatoid arthritis have a slightly better prognosis than UIP without a known cause (IPF).

The best treatment is to avoid the provoking allergen, as chronic exposure can cause permanent damage. Corticosteroids such as prednisolone may help to control symptoms but may produce side-effects.

ILD may be classified according to the cause. One method of classification is as follows:

1. Inhaled substances

- Inorganic

- Silicosis

- Asbestosis

- Berylliosis

- printing workers (eg. carbon bblack, ink mist)

- Organic

- Hypersensitivity pneumonitis

2. Drug-induced

- Antibiotics

- Chemotherapeutic drugs

- Antiarrhythmic agents

3. Connective tissue and Autoimmune diseases

- Rheumatoid arthritis

- Systemic lupus erythematosus

- Systemic sclerosis

- Polymyositis

- Dermatomyositis

4. Infection

- Atypical pneumonia

- Pneumocystis pneumonia (PCP)

- Tuberculosis

- "Chlamydia" trachomatis

- Respiratory Syncytial Virus

5. Idiopathic

- Sarcoidosis

- Idiopathic pulmonary fibrosis

- Hamman-Rich syndrome

- Antisynthetase syndrome

6. Malignancy

- Lymphangitic carcinomatosis

7. Predominantly in children

- Diffuse developmental disorders

- Growth abnormalities deficient alveolarisation

- Infant conditions of undefined cause

- ILD related to alveolar surfactant region

BFL symptoms improve in the absence of the bird proteins which caused the disease. Therefore, it is advisable to remove all birds, bedding and pillows containing feathers from the house as well as washing all soft furnishings, walls, ceilings and furniture. Certain small mammals kept as pets have the same or similar proteins in their fur and feces and so should be removed. Peak flow measurements will indicate a lung condition however a spirometric test on lung capacity and patients ability to move air in and out of the lungs plus in more advanced cases an X-ray test or CT scan is available to confirm whether someone has the disease or not. Steroid inhalers similar to those used for asthma are effective or in cases where the patient finds inhaling difficult high dosages of steroids combined with bone density protecting drugs are used to treat a person with BFL, reducing the inflammation and hopefully preventing scarring. Recovery varies from patient to patient depending on what stage the condition was at when the patient consulted the doctor, the speed of diagnosis and application of the appropriate treatment to prevent residual damage to the lungs and many make a full recovery. However, BFL may reoccur when in contact with birds or other allergens.

Aspiration pneumonia is often caused by a defective swallowing mechanism, often due to a neurological disease or as the result of an injury that directly impairs swallowing or interferes with consciousness. Examples of the former are stroke, Parkinson's disease, and multiple sclerosis, and examples of the latter are some types of dementia, seizures, intoxication, and general anaesthesia. For many types of surgical operations, patients are therefore instructed to take nothing by mouth (nil per os, abbreviated as NPO) for at least four hours before surgery.

Hypersensitivity pneumonitis may also be called many different names, based on the provoking antigen. These include:

Of these types, Farmer's Lung and Bird-Breeder's Lung are the most common. "Studies document 8-540 cases per 100,000 persons per year for farmers and 6000-21,000 cases per 100,000 persons per year for pigeon breeders. High attack rates are documented in sporadic outbreaks. Prevalence varies by region, climate, and farming practices. HP affects 0.4–7% of the farming population. Reported prevalence among bird fanciers is estimated to be 20-20,000 cases per 100,000 persons at risk."