Tobacco smoking is by far the main contributor to lung cancer. Cigarette smoke contains at least 73 known carcinogens, including benzo["a"]pyrene, NNK, 1,3-butadiene and a radioactive isotope of polonium, polonium-210. Across the developed world, 90% of lung cancer deaths in men during the year 2000 were attributed to smoking (70% for women). Smoking accounts for about 85% of lung cancer cases.

Passive smoking—the inhalation of smoke from another's smoking—is a cause of lung cancer in nonsmokers. A passive smoker can be defined as someone living or working with a smoker. Studies from the US, Europe and the UK have consistently shown a significantly increased risk among those exposed to passive smoke. Those who live with someone who smokes have a 20–30% increase in risk while those who work in an environment with secondhand smoke have a 16–19% increase in risk. Investigations of sidestream smoke suggest it is more dangerous than direct smoke. Passive smoking causes about 3,400 deaths from lung cancer each year in the USA.

Marijuana smoke contains many of the same carcinogens as those in tobacco smoke. However, the effect of smoking cannabis on lung cancer risk is not clear. A 2013 review did not find an increased risk from light to moderate use. A 2014 review found that smoking cannabis doubled the risk of lung cancer.

Outdoor air pollutants, especially chemicals released from the burning of fossil fuels, increase the risk of lung cancer. Fine particulates (PM) and sulfate aerosols, which may be released in traffic exhaust fumes, are associated with slightly increased risk. For nitrogen dioxide, an incremental increase of 10 parts per billion increases the risk of lung cancer by 14%. Outdoor air pollution is estimated to account for 1–2% of lung cancers.

Tentative evidence supports an increased risk of lung cancer from indoor air pollution related to the burning of wood, charcoal, dung or crop residue for cooking and heating. Women who are exposed to indoor coal smoke have about twice the risk and a number of the by-products of burning biomass are known or suspected carcinogens. This risk affects about 2.4 billion people globally, and is believed to account for 1.5% of lung cancer deaths.

The treatment of a Pancoast lung cancer may differ from that of other types of non-small cell lung cancer. Its position and close proximity to vital structures (such as nerves and spine) may make surgery difficult. As a result, and depending on the stage of the cancer, treatment may involve radiation and chemotherapy given prior to surgery (neoadjuvant treatment).

Surgery may consist of the removal of the upper lobe of a lung together with its associated structures (subclavian artery, vein, branches of the brachial plexus, ribs and vertebral bodies), as well as mediastinal lymphadenectomy. Surgical access may be via thoracotomy from the back or the front of the chest and modifications

The two major risk factors for esophageal squamous-cell carcinoma are tobacco (smoking or chewing) and alcohol. The combination of tobacco and alcohol has a strong synergistic effect. Some data suggest that about half of all cases are due to tobacco and about one-third to alcohol, while over three-quarters of the cases in men are due to the combination of smoking and heavy drinking. Risks associated with alcohol appear to be linked to its aldehyde metabolite and to mutations in certain related enzymes. Such metabolic variants are relatively common in Asia.

Other relevant risk factors include regular consumption of very hot drinks (over 65 °C)(149 Fahrenheit) and ingestion of caustic substances. High levels of dietary exposure to nitrosamines (chemical compounds found both in tobacco smoke and certain foodstuffs) also appear to be a relevant risk factor. Unfavorable dietary patterns seem to involve exposure to nitrosamines through processed and barbecued meats, pickled vegetables, etc., and a low intake of fresh foods. Other associated factors include nutritional deficiencies, low socioeconomic status, and poor oral hygiene. Chewing betel nut (areca) is an important risk factor in Asia.

Physical trauma may increase the risk. This may include the drinking of very hot drinks.

A Pancoast tumor is a tumor of the pulmonary apex. It is a type of lung cancer defined primarily by its location situated at the top end of either the right or left lung. It typically spreads to nearby tissues such as the ribs and vertebrae. Most Pancoast tumors are non-small cell cancers.

The growing tumor can cause compression of a brachiocephalic vein, subclavian artery, phrenic nerve, recurrent laryngeal nerve, vagus nerve, or, characteristically, compression of a sympathetic ganglion (the superior cervical ganglion), resulting in a range of symptoms known as Horner's syndrome.

Pancoast tumors are named for Henry Pancoast, a US radiologist, who described them in 1924 and 1932.

The two main types (i.e. squamous-cell carcinoma and adenocarcinoma) have distinct sets of risk factors. Squamous-cell carcinoma is linked to lifestyle factors such as smoking and alcohol. Adenocarcinoma has been linked to effects of long-term acid reflux. Tobacco is a risk factor for both types. Both types are more common people over 60 years of age.

Squamous cell carcinoma (SCC) of the lung is more common in men than in women. It is closely correlated with a history of tobacco smoking, more so than most other types of lung cancer. According to the Nurses' Health Study, the relative risk of SCC is approximately 5.5, both among those with a previous duration of smoking of 1 to 20 years, and those with 20 to 30 years, compared to never-smokers. The relative risk increases to approximately 16 with a previous smoking duration of 30 to 40 years, and approximately 22 with more than 40 years.

Roughly 10–35% of NSCLC patients will have drug sensitizing mutations of the "EGFR." The distribution of these mutations have been found to be race-dependent, with one study estimating that 10% of Caucasians but 50% of Asians will be found to have such tumor markers. A number of different EGFR mutations have been discovered, however certain aberrations will result in hyperactive forms of the protein. Patients with these mutations are more likely to have adenocarcinoma histology and be non-smokers or light smokers. These patients have been shown to be sensitized to certain medications which block the EGFR protein known as tyrosine kinase inhibitors specifically, erlotinib, gefitinib or afatinib.

Reliable identification of mutations in lung cancer needs careful consideration due to the variable sensitivity of diagnostic techniques

Thoracic endometriosis affects women aged 15–54, who are between menarche and menopause. It can affect their qualify of life, with catamenial pneumothorax being the most common presentation.

The mediastinum (from Medieval Latin "mediastinus", "midway") is the central compartment of the thoracic cavity surrounded by loose connective tissue, as an undelineated region that contains a group of structures within the thorax. The mediastinum contains the heart and its vessels, the esophagus, trachea, phrenic and cardiac nerves, the thoracic duct, thymus and lymph nodes of the central chest.

Cancer of the stomach, also called gastric cancer, is the fourth-most-common type of cancer and the second-highest cause of cancer death globally. Eastern Asia (China, Japan, Korea, Mongolia) is a high-risk area for gastric cancer, and North America, Australia, New Zealand and western and northern Africa are areas with low risk. The most common type of gastric cancer is adenocarcinoma, which causes about 750,000 deaths each year. Important factors that may contribute to the development of gastric cancer include diet, smoking and alcohol consumption, genetic aspects (including a number of heritable syndromes) and infections (for example, "Helicobacter pylori" or Epstein-Barr virus) and pernicious anemia. Chemotherapy improves survival compared to best supportive care, however the optimal regimen is unclear.

Prognosis depends on how early the cancer is discovered and treated. For the least aggressive grade, about 90% of patients survive more than five years after diagnosis. People usually have a good survival rate at the low grade volume of cancer. For the most aggressive grade, only 10% of patients will survive one year.

Tumors may recur in the future. Follow up scans are extremely important for chondrosarcoma to make sure there has been no recurrence or metastasis, which usually occurs in the lungs.

Patient response to treatment will vary based on age, health, and the tolerance to medications and therapies.

Metastasis occurs in about 39% of patients, most commonly to the lung. Features associated with poor prognosis include a large primary tumor (over 5 cm across), high grade disease, co-existent neurofibromatosis, and the presence of metastases.

It is a rare tumor type, with a relatively poor prognosis in children.

In addition, MPNSTs are extremely threatening in NF1. In a 10-year institutional review for the treatment of chemotherapy for MPNST in NF1, which followed the cases of 1 per 2,500 in 3,300 live births, chemotherapy did not seem to reduce mortality, and its effectiveness should be questioned. Although with recent approaches with the molecular biology of MPNSTs, new therapies and prognostic factors are being examined.

The cause of thoracic endometriosis is unknown. People with multiple previous operations are more prone, due to the manipulation that may cause embolisation of the endometrial tissue into the thoracic cavity. Some thoracic endometriosis patients have been described as having a congenital defect in the diaphragm. There is also an association between thoracic and pelvic endometriosis.

Diaphragmatic injuries are present in 1–7% of people with significant blunt trauma and an average of 3% of abdominal injuries.

A high body mass index may be associated with a higher risk of diaphragmatic rupture in people involved in vehicle accidents. It is rare for the diaphragm alone to be injured, especially in blunt trauma; other injuries are associated in as many as 80–100% of cases. In fact, if the diaphragm is injured, it is an indication that more severe injuries to organs may have occurred. Thus, the mortality after a diagnosis of diaphragmatic rupture is 17%, with most deaths due to lung complications. Common associated injuries include head injury, injuries to the aorta, fractures of the pelvis and long bones, and lacerations of the liver and spleen. Associated injuries occur in over three quarters of cases.

Pancreatic cancer is the fifth-most-common cause of cancer deaths in the United States, and the seventh most common in Europe. In 2008, globally there were 280,000 new cases of pancreatic cancer reported and 265,000 deaths. These cancers are classified as endocrine or nonendocrine tumors. The most common is ductal adenocarcinoma. The most significant risk factors for pancreatic cancer are advanced age (over 60) and smoking. Chronic pancreatitis, diabetes or other conditions may also be involved in their development. Early pancreatic cancer does not tend to result in any symptom, but when a tumor is advanced, a patient may experience severe pain in the upper abdomen, possibly radiating to the back. Another symptom might be jaundice, a yellowing of the skin and eyes.

Pancreatic cancer has a poor prognosis, with a five-year survival rate of less than 5%. By the time the cancer is diagnosed, it is usually at an advanced, inoperable stage. Only one in about fifteen to twenty patients is curative surgery attempted. Pancreatic cancer tends to be aggressive, and it resists radiotherapy and chemotherapy.

A significant complication of diaphragmatic rupture is traumatic diaphragmatic herniation: organs such as the stomach that herniate into the chest cavity and may be strangulated, losing their blood supply. Herniation of abdominal organs is present in 3–4% of people with abdominal trauma who present to a trauma center.

The cause is unknown. Patients may have a history of enchondroma or osteochondroma. A small minority of secondary chondrosarcomas occur in patients with Maffucci syndrome and Ollier disease.

It has been associated with faulty isocitrate dehydrogenase 1 and 2 enzymes, which are also associated with gliomas and leukemias.

Many vertebrates, especially reptiles, have cervical ribs as a normal part of their anatomy rather than a pathological condition. Some sauropods had exceptionally long cervical ribs; those of "Mamenchisaurus hochuanensis" were nearly 4 meters long.

In birds, the cervical ribs are small and completely fused to the vertebrae.

In mammals the ventral parts of the transverse processes of the cervical vertebrae are the fused-on cervical ribs.

Recent studies have also found a high percent of cervical ribs in woolly mammoths. It is believed that the decline in mammoth numbers may have forced inbreeding within the species which in turn has increased the number of mammoths being born with cervical ribs. Cervical ribs have been connected with leukaemia in human children, so it has given scientists new evidence to believe that the mammoth's extinction was attributed to the condition.

Birt-Hogg-Dubé Syndrome patients, families, and caregivers are encouraged to join the NIH Rare Lung Diseases Consortium Contact Registry. This is a privacy protected site that provides up-to-date information for individuals interested in the latest scientific news, trials, and treatments related to rare lung diseases.

For individuals who survive the initial crush injury, survival rates are high for traumatic asphyxia.

Lung hernia (Sibson hernia) is a protrusion of lung outside of thoracic wall. In 20% patients with lung hernia, the incidence is congenital. In 80% of the cases, the hernia is noted after chest trauma, thoracic surgery or certain pulmonary diseases. Congenital hernia occurs because of the weakness of the suprapleural membrane or neck muscles. In pulmonary diseases such as asthma, frequent coughing can lead to high intra thoracic pressure, causing the lung to herniate out. Lung hernia may occur near the neck (cervical), between the ribs (intercostal), near the vertebrae (paravertebral) or near the sternum (parasternal).

There are few studies of the long-term outcomes of patients treated for MALS. According to Duncan, the largest and more relevant late outcomes data come from a study of 51 patients who underwent open surgical treatment for MALS, 44 of whom were available for long-term follow-up at an average of nine years following therapy. The investigators reported that among patients who underwent celiac artery decompression and revascularization, 75% remained asymptomatic at follow-up. In this study, predictors of favorable outcome included:

- Age from 40 to 60 years

- Lack of psychiatric condition or alcohol use

- Abdominal pain that was worse after meals

- Weight loss greater than 20 lb (9.1 kg)

Soft tissue sarcomas have been linked within families, so it is hypothesized that neurofibrosarcoma may be genetic, although researchers still do not know the exact cause of the disease. Evidence supporting this hypothesis includes loss of heterozygosity on the 17p chromosome. The p53 (a tumor suppressor gene in the normal population) genome on 17p in neurofibrosarcoma patients is mutated, increasing the probability of cancer. The normal p53 gene will regulate cell growth and inhibit any uncontrollable cell growth in the healthy population; since p53 is inactivated in neurofibrosarcoma patients, they are much more susceptible to developing tumors.

No treatment is needed for correcting lung hernias. Some surgeons offer cosmetic surgery to remove the protruding mass.