The risk may be reduced by administering a non-particulate antacid (e.g. Sodium Citrate) or an H-antagonist like Ranitidine.

Historically it is said that a patient is at risk if they have:

- Residual gastric volume of greater than 25ml, with

- pH of less than 2.5

However these are indirect measurements and are not factors that directly influence aspiration risk.

Patients with a high risk should have a rapid sequence induction. High risk is defined as these factors:

1. Non-elective surgical procedure

2. Light anaesthesia/unexpected response to stimulation

3. Acute or chronic, upper or lower GI pathology

4. Obesity

5. Opioid medication

6. Neurological disease, impaired conscious level, or sedation

7. Lithotomy position

8. Difficult intubation/airway

9. Gastrointestinal reflux

10. Hiatal hernia

Pulmonary aspiration of acidic material (such as stomach acid) may produce an immediate primary injury caused by the chemical reaction of acid with lung parenchyma, and a later secondary injury as a result of the subsequent inflammatory response.

Risk factors for pulmonary aspiration include conditions which depress the level of consciousness (such as traumatic brain injury, alcohol intoxication, drug overdose, and general anesthesia). A decreased gag reflex, upper esophageal sphincter and lower esophageal sphincter tone, gastroesophageal reflux, full stomach, as well as obesity, stroke, and pregnancy can all increase the risk of aspiration in the semiconscious. Tracheal intubation or presence of a gastric tube (for example, a feeding tube) may also increase the risk.

Sixty percent of people with acute interstitial pneumonitis will die in the first six months of illness. The median survival is 1½ months.

However, most people who have one episode do not have a second. People who survive often recover lung function completely.

Fire breather’s pneumonia is caused by the entrance of hydrocarbon fuels into the bronchial tree, usually due to accidental aspiration or inhalation during a fire performance show. Fire breathing, or fire blowing, is the act of creating a plume of fire by blowing a mouthful of fuel in a fine mist (atomization) over a source of ignition. Fire eating, or fire swallowing, is the act of putting a flaming object into the mouth and extinguishing it.

In both disciplines, the performer holds their breath until the air is clear of vapors, so as to not inhale the hazardous fumes. However, improper technique or an accident can lead to ingestion, inhalation, or aspiration of fine droplets or vapors. Fire breathing and fire eating are separate acts, but the terms are sometimes erroneously used interchangeably in the literature.

Fuel ingestion can also occur due to siphoning by mouth of fuel products.

Once inhaled, these fuels induce an inflammatory reaction in lung tissue. They are not metabolized by tissue enzymes, but undergo emulsification and become engulfed by macrophages which, with time, may disintegrate and release oily substances surrounded by fibrous tissue and giant cells.

Fire breathing is typically performed with a high flash point fuel, such as lamp oil (liquid paraffin), while fire eating is performed with low flash point fuels, such as white gas or naphtha. Highly purified fuels are preferred by fire performers due to their minimized toxicity, but other, more dangerous fuels may sometimes be used, such as ethanol, isopropanol, kerosene, gasoline, or charcoal lighter fluid. All fuels run the risk of causing pneumonitis if inhaled, however longer chain oils are more persistent than smaller molecules. Alcohols and volatile naphthas are likely to be absorbed or expelled from the body by evaporation and respiration.

Acute interstitial pneumonitis occurs most frequently among people older than forty years old. It affects men and women equally. There are no known risk factors; in particular, smoking is not associated with increased risk.

"Fire-eater's lung" is an important variant of hydrocarbon pneumonitis, which typically involves adolescents or young adults who are exposed through mishap during flame-blowing performances using a variety of different flammable materials. The substances used overlap with some of the pediatric exposures (kerosene, gasoline) but can also include other hydrocarbons such as jet fuel and, in France, an aromatic hydrocarbon enriched petroleum-distillate called "kerdan". There has also been a case of citronella oil aspiration in a fire-eater. As with hydrocarbon pneumonitis in children, fire-eater's lung can also be complicated by pneumatocele. Although the term "acute lipoid pneumonia" has been used to refer to the "fire-eater's lung" syndrome, this is a misnomer.

Sources of such lipids could be either exogenous or endogenous.

Exogenous: from outside the body. For example, inhaled nose drops with an oil base, or accidental inhalation of cosmetic oil. Amiodarone is an anti-arrythmic known to cause this condition. Oil pulling has also been shown to be a cause. At risk populations include the elderly, developmentally delayed or persons with gastroesophageal reflux. Switching to water-soluble alternatives may be helpful in some situations.

Endogenous: from the body itself, for example, when an airway is obstructed, it is often the case that distal to the obstruction, lipid-laden macrophages (foamy macrophages) and giant cells fill the lumen of the disconnected airspace.

The following are precautionary measures that can be taken to avoid the spread of bagassosis:

1. Dust control-prevention /suppression of dust such as wet process, enclosed apparatus, exhaust ventilation etc. should be used

2. Personal protection- masks/ respirators

3. Medical control- initial medical examination & periodical checkups of workers

4. Bagasse control- keep moisture content above 20% and spray bagasse with 2% propionic acid

Studies reflecting international frequency demonstrated that 2-3% of all infants in NICUs develop pulmonary interstitial emphysema. When limiting the population studied to premature infants, this frequency increases to 20-30%, with the highest frequencies occurring in infants weighing fewer than 1000 g.

The prevalence of pulmonary interstitial emphysema widely varies with the population studied. In a 1987 study 3% of infants admitted to the neonatal intensive care unit (NICU) developed pulmonary interstitial emphysema.

In one study, peanuts were the most common obstruction. In addition to peanuts, hot dogs, and grapes, latex balloons are also a serious choking hazard in children that can result in death. A latex balloon will conform to the shape of the trachea, blocking the airway and making it difficult to expel with the Heimlich maneuver.

Regardless of cause, UIP is relentlessly progressive, usually leading to respiratory failure and death without a lung transplant. Some patients do well for a prolonged period of time, but then deteriorate rapidly because of a superimposed acute illness (so-called "accelerated UIP"). The outlook for long-term survival is poor. In most studies, the median survival is 3 to 4 years. Patients with UIP in the setting of rheumatoid arthritis have a slightly better prognosis than UIP without a known cause (IPF).

Hydrocarbon pneumonitis is a kind of chemical pneumonitis which occurs with oral ingestion of hydrocarbons and associated aspiration. It occurs prominently among children, accounting for many hospital admissions each year. Common hydrocarbons involved are mineral spirits, mineral seal oil (common in furniture polish), lamp oil, kerosene (paraffin), turpentine (pine oil), gasoline, and lighter fluid. Pneumatocele is a complication of hydrocarbon pneumonitis. In both childhood and adult pneumonitis, hydrocarbon aspiration occurs at the time of initial ingestion event or subsequently with vomiting. Low viscosity of an ingested hydrocarbon is considered a major factor promoting aspiration (presumably for mechanical reasons). Contrary to aspiration hydrocarbon pneumonitis, hydrocarbon (solvent) vapor inhalation manifests primarily in either central nervous system or cardiac effects.

Bagassosis, an interstitial lung disease, is a type of hypersensitivity pneumonitis attributed to exposure to moldy molasses (bagasse).

The mortality rate of meconium-stained infants is considerably higher than that of non-stained infants; meconium aspiration used to account for a significant proportion of neonatal deaths. Residual lung problems are rare but include symptomatic cough, wheezing, and persistent hyperinflation for up to five to ten years. The ultimate prognosis depends on the extent of CNS injury from asphyxia and the presence of associated problems such as pulmonary hypertension. Fifty percent of newborns affected by meconium aspiration would die fifteen years ago; however, today the percent has dropped to about twenty.

ILD may be classified according to the cause. One method of classification is as follows:

1. Inhaled substances

- Inorganic

- Silicosis

- Asbestosis

- Berylliosis

- printing workers (eg. carbon bblack, ink mist)

- Organic

- Hypersensitivity pneumonitis

2. Drug-induced

- Antibiotics

- Chemotherapeutic drugs

- Antiarrhythmic agents

3. Connective tissue and Autoimmune diseases

- Rheumatoid arthritis

- Systemic lupus erythematosus

- Systemic sclerosis

- Polymyositis

- Dermatomyositis

4. Infection

- Atypical pneumonia

- Pneumocystis pneumonia (PCP)

- Tuberculosis

- "Chlamydia" trachomatis

- Respiratory Syncytial Virus

5. Idiopathic

- Sarcoidosis

- Idiopathic pulmonary fibrosis

- Hamman-Rich syndrome

- Antisynthetase syndrome

6. Malignancy

- Lymphangitic carcinomatosis

7. Predominantly in children

- Diffuse developmental disorders

- Growth abnormalities deficient alveolarisation

- Infant conditions of undefined cause

- ILD related to alveolar surfactant region

Airway obstruction may cause obstructive pneumonitis or post-obstructive pneumonitis.

Endogenous lipoid pneumonia and non-specific interstitial pneumonitis has been seen prior to the development of pulmonary alveolar proteinosis in a child.

Radiation-induced lung injury is a general term for damage to the lungs which occurs as a result of exposure to ionizing radiation. In general terms, such damage is divided into early inflammatory damage ("radiation pneumonitis") and later complications of chronic scarring ("radiation fibrosis"). Pulmonary radiation injury most commonly occurs as a result of radiation therapy administered to treat cancer.

Foreign body aspiration occurs when a foreign body enters the airways and causes choking. A foreign body in the bronchi usually causes a cough.

Conditions which commonly involve hemoptysis include bronchitis and pneumonia, lung cancers and tuberculosis. Other possible underlying causes include aspergilloma, bronchiectasis, coccidioidomycosis, pulmonary embolism, pneumonic plague, and cystic fibrosis. Rarer causes include hereditary hemorrhagic telangiectasia (HHT or Rendu-Osler-Weber syndrome), Goodpasture's syndrome, and granulomatosis with polyangiitis. In children, hemoptysis is commonly caused by the presence of a foreign body in the airway. The condition can also result from over-anticoagulation from treatment by drugs such as warfarin.

Blood-laced mucus from the sinus or nose area can sometimes be misidentified as symptomatic of hemoptysis (such secretions can be a sign of nasal or sinus cancer, but also a sinus infection). Extensive non-respiratory injury can also cause one to cough up blood. Cardiac causes like congestive heart failure and mitral stenosis should be ruled out.

The origin of blood can be identified by observing its color. Bright-red, foamy blood comes from the respiratory tract, whereas dark-red, coffee-colored blood comes from the gastrointestinal tract. Sometimes hemoptysis may be rust-colored.

The most common cause of minor hemoptysis is bronchitis.

- Lung cancer, including both non-small cell lung carcinoma and small cell lung carcinoma.

- Sarcoidosis

- Aspergilloma

- Tuberculosis

- Histoplasmosis

- Pneumonia

- Pulmonary edema

- Pulmonary embolism

- Foreign body aspiration and aspiration pneumonia

- Goodpasture's syndrome

- Granulomatosis with polyangiitis

- Eosinophilic granulomatosis with polyangiitis (Churg-Strauss syndrome)

- Bronchitis

- Bronchiectasis

- Pulmonary embolism

- Anticoagulant use

- Trauma

- Lung abscess

- Mitral stenosis

- Tropical eosinophilia

- Bleeding disorders

- Hughes-Stovin Syndrome and other variants of Behçet's disease

- Squamous Cell Carcinoma Of Esophagus

Besides complications of surgery and anesthesia in general, there may be drainage, swelling, or redness of the incision, gagging or coughing during eating or drinking, or pneumonia due to aspiration of food or liquids. Undesirable complications are estimated to occur in 10-30% of cases. If medical therapy is unsuccessful and surgery cannot be performed due to concurrent disease (such as heart or lung problems) or cost, euthanasia may be necessary if the animal's quality of life is considered unacceptable due to the disease.